实验一对硝基苯乙腈的制备.docVIP

实验一、对硝基苯乙腈的制备 8h 教学目的 1．通过本实验，掌握硝化反应的原理。 2．熟悉和掌握硝化反应常见的方法及各自特点。 3．进一步巩固和熟悉硝化反应的实验操作以及混酸配制方法。 4．了解硝化反应中的副产物以及减少副反应的方法。 p-NITROBENZYL CYANIDE [α-Tolunitrile, p-nitro-] 原料与试剂 浓硫酸 CP 27.5mL 浓硝酸 CP 27.5mL 苯乙腈 CP 10g 95％乙醇 CP 50mL 1. Procedure In a 250-ml. round-bottomed flask, fitted with a stopper holding a dropping funnel and a mechanical stirrer, is placed a mixture of 27.5 cc. (0.43 moles) of concentrated nitric acid (sp. gr. 1.42) (Note 1) and 27.5 cc. (0.49 moles) of concentrated sulfuric acid (sp. gr. 1.84). This is cooled to 10° in a freezing mixture, and 10 g. (0.85 mole) of benzyl cyanide (free from alcohol and water) (Note 2) is run in slowly, at such a rate that the temperature remains at about 10° and does not exceed 20°. After all the benzyl cyanide has been added (about one hour), the ice bath is removed, and the mixture is stirred for one hour and then poured onto 120 g. of crushed ice. A pasty mass slowly separates; more than half of this mass is p-nitrobenzyl cyanide, the other constituents being o-nitrobenzyl cyanide, and a variable amount of an oil which resists hydrolysis; apparently no dinitro compounds are formed. The mass is filtered on a porcelain funnel with suction, pressed well to remove as much oil as possible, and dissolved in 50 cc. of boiling 95 per cent alcohol. On cooling, p-nitrobenzyl cyanide crystallizes; the mother liquor, on distillation, gives an impure alcohol which can be used for the next run. Recrystallization from 55 cc. of 80 per cent alcohol (sp. gr. 0.86 to 0.87) yields 7.0–7.5 g. (50–54 per cent of the theoretical amount) of a product which melts at 115–116°. This product is satisfactory for most purposes, and incidentally for the preparation of p-nitrophenylacetic acid. Occasionally it must be free even from traces of the ortho compound; if so, it should be crystallized again from 80 per cent alcohol; it then melts at 116–117°. 2. Notes 1. Fuming nitric acid m