电动给水泵切换操作票21(欧阳智修改)..docVIP

热机操作票Thermal Mechanism Operation Order 神华国华（印尼）南苏发电有限公司PT. GH EMM INDONESIA 编号(Serial Number)：T21 操作开始时间(Start time)： 操作终了时间(End time): 操作任务(OperationTask) 机给水泵切换switch unit ___ feed water pumps 安健环风险（工作安全分析）SHE Risk（Working safety analysis） 序号 No. 安健环风险描述 SHE Risk Description 风险类型Risk type 相应控制措施 Related Measures S H E 转动机械伤人. Rotating part may hurt people. √ 启动时人站在泵的轴向位置且保持一定距离，注意地面和周围环境. Stand on the axial position of stator and keep a distance, pay attention to ground and surroundings. 操作失误，水位波动大. Misoperation and water level fluctuates much. √ 给水泵切换过程中应缓慢进行，给水控制转手动，采用一台泵升速，另一台泵降速的方法；并关注汽包水位的变化。当启动的给水泵完全接带负荷后方可停运另一台给水泵.Be slowly in the switch operation, feed water control turn to manual, increase rotating speed of one pump and decrease rotation speed of another pump at the same time; pay attention to water level change of drum. Stop the pump after the new started pump take over the load the pump. 个人防护用品Personal protective equipment 安全帽Safety helmet 防静电服ESD clothes. 手套Gloves. 防尘口罩Dust mask. 绝缘鞋/靴 防酸服Acid resistant clothes 防尘帽Dust cap 安全绳/带 防静电鞋/靴 雨衣Raincoat 护耳器Ear plug 正压式呼吸器SCBA 防酸鞋/靴 塑胶手套Plastic gloves 护目眼镜Eye protector 呼吸器Breathing apparatus 橡胶鞋/靴 绝缘手套Insulating gloves 护脸设备Face protector 其它防护用品Others： 风险分析人（Risk Analyst）： 操作成员认可以上措施签名（Operator signature after confirming the measures）： 执行Done（√） 序号 No 操 作 内 容 Operation steps 时 Hr 分MiN 1 接值长令将____给水泵转由____给水泵运行，____泵停运作备用。Receive order of switch ___ feed water pump running to ___ feed water pump running, put ___ feed water pump standing by. 2 就地检查确认____给水泵具备启动条件。Check ___ feed water pump is ready to start up. 3 将____备用给水泵备用解除。relieve ____ feed water pump standby。 4 将____备用给水泵勺管控制切至手动位置。Turn spoon control of ___ feed water pump to manual. 5 将____备用给水泵勺管开度在最小位置。Minim the openness of ___ feed water pump spoon. 6 检查____备用给水泵再循环门确已开启。Check recycling valve of ___ feed water pump is actually open. 7 检查___备用给水泵辅助油泵运行，就地润滑油压正常____MPa，确认就地值班员站在事故按钮旁后启动____