低碱度高镁烧结矿性能研究.pdfVIP

低碱度高镁烧结矿性能的研究 ·1 · 低碱度高镁烧结矿性能的研究 武 轶 金 俊 熊德怀 (马鞍山钢铁股份有限公司技术中心，马鞍山 243000) 摘 要 增加烧结矿中MgO 含量，从而提高高炉渣中MgO 含量是改善高炉炉渣性能的主要措施之一。本文介绍 了在低碱度的情况下增加烧结矿MgO 含量对烧结矿性能的影响。试验研究表明：三种高镁渣方案中，高铝低碱度 高镁渣方案的烧结矿熔滴性能虽有较大改善，但其成品率、固体燃耗和TI 等指标均较差；中等铝低碱度高镁渣方 案的烧结生产率和转鼓强度略好于中等铝低碱度高镁渣(高炉加白云石)方案，该方案较为可行。 关键词 低碱度 高镁 高铝 炉渣性能 Study on Properties of Low-Basicity and High-MgO Sinter Wu Yi Jin Jun Xiong Dehuai (Ma’anshan Iron and Steel Co., Ltd. Technology Center, Ma’anshan, 243000) Abstract By taking measures of decreasing basicity and increasing MgO, it was realized that performances of high-Al O 2 3 slag is improved. This paper studies on the effects of this measure on sintering process. The sintering test results show that in three high-MgO plans, sinter melting properties were improved in high-Al O and low-R and high-MgO slag plan, but 2 3 sinter yield and TI reduced and solid fuel rate increased. Sintering productivity and TI in Mid-Al2O3 and low-R and high-MgO slag plan was slightly better than sinter technical index in Mid-Al2O3 and low-R and high-MgO slag plan (adding dolomite in BF). This plan was more feasible. Key words low-basicity, high-MgO, high-Al O , slag properties 2 3 近年来，随着国内钢铁行业突飞猛进的发展和整体产能的不断扩张，进口铁矿石需求量呈逐年几何递增 态势，国外铁矿石供应商纷纷扩产。同时，进口铁矿石的品质呈现不断劣化的趋势，铁矿石的全铁品位逐步 下降[1]、Al O 含量逐渐升高。 2 3 高炉高Al O 渣冶炼一直是冶金工作者关心的敏感问题。当终渣中Al O 过高时，炉渣熔点高、粘度大， 2 3 2 3 易造成炉缸堆积，