2011年重庆重点建设项目（桥梁和高速公路）.docVIP

格栅增强浇筑式性能研究高博1，张华2，王民1，薛昕1，杨波1 （1.重庆智翔铺道技术工程有限公司，重庆400060，2.招商局重庆交通科研设计院有限公司，重庆400060）摘 要：抗疲劳开裂高温车辙阻止推移关键词：桥面铺装；浇筑式；玻纤格栅；车辙；Reseach on Grid reinfoced gussasphalt (1. Chognqing Zhixiang Paving Rechnology Engineering Co., Ltd. Chongqing 400060, china; 2. China Merchants Chongqing Communications Research Design Institute Co., Ltd. Chongqing 400060, china) Abstract: the Grid reinfoced gussasphalt was introduced in thispaper, This paper analyzes the function of grid in the gussasphalt deck paving, which the main functions are developing the performance of fatigue resistance, enhancing high-temperature rut resistance, strengthening gussasphalt integrity and its processing prevention. After doing the rut test, beam bending test under three kinds of temperature and shear test respectively on steel wire and glass fiber grid reinfoced gussasphalt, and analyzing bending resistance of grid reinfoced gussasphalt by threshold of strain energy, the results showed that the rutting dynamic stability of the steel wire grid reinfoced gussasphalt is developed one times and the glass fiber grid reinfoced gussasphalt is 0.5 times compared to gussasphalt at 60℃. Meanwhile, steel grid and glass fiber grid improved the bending crack resistance of ordinary gussasphalt, and developed the bending strength and strains under high temperature. On the other hand, bending resistance of grid reinfoced gussasphalt is much better than ordinary gussasphalt by the analysis of threshold of strain energy. Moreover, steel wire grid could weaken the internal shear capacity of gussasphalt, however, the fiber glass grid is on the contrary. Key words: deck pavment；gussasphalt；curvature strain energy；rutting；three-point bending test；shear testing 浇筑式沥青混凝土是按照施工工艺分类标准确定的一种沥青混凝土，结构上属于悬浮密级配。它的特点是在施工温度（220-240℃）条件下，沥青混合料呈流淌状态，一般不需要碾压，只需用简单的摊铺整平机具即可完成施工，并能达到规定的密实度和平整度。浇筑式沥青混凝土本身具有拌和温度高、矿粉含量高、沥青含量高以及拌和时间长等特点[1]。它与热压沥青混凝土不同的是其空隙率很小，而且内部空隙不连续，由于整体性强，层内不存在水损害、老化等病害。浇筑式的特点决定了其适合用于桥面铺装，在欧洲日本得到了广泛的发展和应用浇筑式在德国被称为Gussasph