300 MW 汽轮机危急遮断系统优化.pdfVIP

第29 卷第4 期 机 电 工 程 Vol. 29 No.4 A-PDF Split DEMO : Purchase from www.A-PDF.com to remove the watermark 2012 年4 月 Journal of Mechanical Electrical Engineering Apr. 2012 300MW汽轮机危急遮断系统优化 叶 非 （上海电力股份有限公司 吴泾热电厂，上海 200241） 摘要：为提高现有300 MW 发电机组汽轮机危急遮断保护系统（ETS）的可靠性，将成熟的PLC 控制等技术应用到保护系统控制逻辑的 实现中。首先从危急遮断保护系统的原理入手进行了分析，建立了被测点和控制量之间的逻辑关系，采用了PLC 控制等技术，来对双 网双机双电源热备进行了优化。最后，对吴泾热电厂2 台300 MW 机组汽轮机危急遮断保护系统进行了优化。研究结果表明：采用该 技术进行优化能极大地避免由于单点测量故障、单控制回路和单电源引起的发电机组汽轮机危急遮断保护系统的非正常保护动作。 关键词：危急遮断系统；继电器控制逻辑；压力变送器 中图分类号：TM311 ；TM588 文献标志码：A 文章编号：1001-4551 （2012 ）04-0439-04 Optimizationofturbineemergencytripsystemwith300MW YE Fei （Wujing Thermoelectric Plant ，Shanghai Electric Power Co. Ltd. ，Shanghai 200241 ，China） Abstract：In order to improve reliability of the existing emergency trip system （ETS ）of the 300 MW unit in a power plant ，programmable logic controller （PLC ）technology were applied to the protection system to realize the control logic. Firstly ，the logic connection between measure points and manipulated variables was established based on the protection principles ，then ，the double nets dual machine double power supply for the PLC control system was put forward to optimize it. The optimization job of the emergency trip system of two 300 MW units was completed in Wujing Thermoelectric. The results show that using the optimization technology will greatly avoid the single point measurement fault ，abnormal protection movements caused by single control circuit and single power. Keywords：emergency trip system （ETS ）；relay logic controller ；pressure transmitter 0 引 言 1 危急遮断系统（ETS ）的发展 国内300 MW