23二羟基丙基二硫代碳酸钠对铜铅硫化矿可浮性的影响（英文版）.pdfVIP

Trans. Nonferrous Met. Soc. China 24(2014) 3343−3347 Influence of sodium 2,3-dihydroxypropyl dithiocarbonate on floatability of chalcopyrite and galena 1 1 1,2 Zheng-jie PIAO , De-zhou WEI , Zhi-lin LIU 1. College of Resources and Civil Engineering, Northeastern University, Shenyang 110004, China; 2. Faculty of Resource and Environmental Engineering, Jiangxi University of Science and Technology, Ganzhou 341000, China Received 27 May 2013; accepted 30 November 2013 Abstract: Sodium 2,3-dihydroxypropyl dithiocarbonate (SGX), which contains —OH and —CSS— in the molecule, was used to explore selective depression of galena from chalcopyrite in the flotation tests with ammonium dibutyl dithiophosphate (DDTP), and zeta potential and adsorption measurements were performed to study the interaction between SGX and minerals. The flotation tests of single minerals show that SGX has slight activation on chalcopyrite and strong depression on galena in the whole pH range. With SGX dosage increasing, the recovery of galena decreases rapidly, while that of chalcopyrite increases slightly. At pH=6, the copper grade and recovery of concentrate are 29.52% and 82.15% respectively when mixture of two minerals is tested. Zeta potential and adsorption measurements indicate that SGX has strong adsorption on galena and slight adsorption on chalcopyrite. Key words: sodium 2,3-dihydroxypropyl dithiocarbonate; depression; flotation; chalcopyrite; galena sulfite could depress galena well, but depress 1 Introduction