基于磁敏探头的油管材质识别.PDFVIP

, , , ( 中国石油大学( 北京) 机电工程学院油气安全工程技术研究中心, 北京 102249) : 油管原有标记的丢失导致 同级别可再用油管的混杂, 因而造成巨大的经济损失和安 全隐患基于涡流检测方法, 采用磁敏探头, 对油田大量使用的J55 和N80 型再用油管开展材质 识别试验结果表明, 响应电压大小受到提离磁敏探头方向和激励频率等的影响在磁敏探头与 油管方向垂直时, 施加100~ 260 Hz 正弦激励频率的电流, 两种油管的响应电压具有较好的线性 关系; 在 150 Hz 激励频率下, 两种油管的响应电压差别明显, 现场识别准确率高于97% : 涡流检测; 材质识别; 油管; 激励频率 : T G 115. 28 : A : 20 11) 0200 1604 Material Recognition of Oil Tube Based on Eddy Current Testing MA Juan, FAN JianChun, ZHAN LaiBin, LUAN Ming ( Faculty f Mechanical and Electr nic, Engineering Research Center f r Oil Gas Engineering, China University f Pet r leum ( Beijing) , Beijing 102249, China) Abstract: L sses f the riginal marker result in a c nfusi n f il pipelines that can be recycled, w hich lead t huge securit y risks and great ec n mic l sses. In this paper, material identificati n tests f c mm nly used J55 and N80 il tubes are c nducted by eddy current meth d. Results sh w the size f resp nse v ltage is affected by lift ff, the directi n f magnetic pr be, the ex citati n frequency, etc. When magnetic pr be is perpendicular t tubing , resp nse v ltage f tw kinds f pipelines has g d linear relati nship w ith the 100~ 260 H z sinus idal ex citati n frequency , and resp nse v ltage f J55 is significantly different fr m that f N 80 at the sinus idal ex citati n frequency f 150 Hz. A s a result, the rec gniti n accuracy f these tw kinds f pipeline is higher than 97% . Keywords: Eddy current testing; Material rec gnit i n; Oil tube; Ex citati n frequency , , [ 3] , , , , [ 4- 6] , , , , , N80 J55 ; ,