基于热刺激电流的硅橡胶合成绝缘子老化诊断方法初探.pdfVIP

第 27 卷 第 21 期 中 国 电 机 工 程 学 报 Vol.27 No.21 Jul. 2007 2007 年 7 月 Proceedings of the CSEE ©2007 Chin.Soc.for Elec.Eng. 0258-8013 (2007) 21-0007-06 TN21 A 470 40 文章编号： 中图分类号： 文献标识码： 学科分类号： ⋅ 基于热刺激电流的硅橡胶合成绝缘子 老化诊断方法初探 梁 英，丁立健，李成榕，杨 堃，屠幼萍 (华北电力大学高电压与电磁兼容北京市重点实验室，北京市 昌平区 102206) Primary Research on the Diagnosis of Aging Silicone Rubber Insulators Using Thermally Stimulation Current LIANG Ying, DING Li-jian, LI Cheng-rong, YANG Kun, TU You-ping (Beijing Key Laboratory of High Voltage EMC, North China Electric Power University, Changping District, Beijing 102206, China) ABSTRACT: Diagnosis of aging silicone rubber(SIR) 关键词：热刺激电流；硅橡胶；合成绝缘子；老化诊断；陷 insulator using thermally stimulation current(TSC) technique is 阱电荷 investigated. Firstly, based on experimental results of the 0 引言 influence of test conditions on SIR TSC characteristics, proper 硅橡胶合成绝缘子以其显而易见的优越性在 TSC test parameters have been concluded with corresponding 电力系统中得到了广泛应用。由于其外绝缘材质为 developing trends of trapped charges. Then TSC of two different insulators made from the same manufacturer were 有机材料，长年带电运行在户外的恶劣条件下，硅 measured under given test parameters. It is found that the TSC 橡胶合成绝缘子的耐老化性一直是研究人员普遍 results of new and old insulators are obviously different. 关注的问题，尤其是老化程度的诊断及评价方法引 Considering the analysis of hydrophobicity and microstructure, 起了现场及有关人员的高度重视[1-5] 。目前，合成绝 it is indicated that there might be some relationship among the 缘子老化诊断的方法主要靠肉眼观察及老化前后 TSC, hydrophobicity and microstructure. It is believed tha