2×660MW超超临界燃煤空冷机组新建工程100%容量锅炉给水泵技术协议.doc

国电建投内蒙古能源有限公司 布连电厂一期2×660MW超超临界 燃煤空冷机组新建工程Bulian Power Plant 2×660MW Extra-supercritical Coal-fired Air-colded Unit New Project 100%容量锅炉给水泵 100% Capacity Boiler Feed Water Pump 技术协议 附件1 技术规范APPENDIX 1 TECHNICAL SPECIFICATION 1 1 总则General 1 2 工程概况Project outline 4 3 设计和运行条件Design and Operation Condition 11 4 技术条件Technical Conditions 22 5 质量保证、试验、监造及验收Quality guaranty, Testing, Supervision (Inspection）and Performance Acceptance 45 6 包装、运输、装卸 Package , Transportation, loadingunloading 51 7 设计与供货界限及接口规则 Design and supply scope Interface regulations 54 8 锅炉给水泵热控技术要求Technical requirement of instrumentation control on boiler feedwater pump 56 附件2 供货范围Appendix 2 Scope of Supply 67 1 一般要求General Requirements 67 2 供货范围Scope of Supply 67 附件3 技术资料及交付进度Appendix 3 Technical Documentation and Submission Schedule 74 1 一般要求General Requirements 74 2 资料提交的基本要求Basic Rrequirements of Document Submission 76 附件4 交货进度Appendix 4 Delivery Schedule 80 附件5 监造、检验和性能验收试验Appendix 5 supervision ，inspection and approval test 81 1 概述General Description 81 2 工厂检验Workshop Inspection 81 3. 设备监造Equipment Supervision 83 4 性能验收试验performance acceptance test 87 附件6 技术服务与联络Appendix6 Technical service and design liaison 89 1．卖方现场技术服务The technical service of the seller on site 89 2 培训Training 91 3 设计联络会Design Liaison 92 附件7 分包与外购 95 附件8 大部件情况Appendix 8 Oversize information 96 附件1 技术规范APPENDIX 1 TECHNICAL SPECIFICATION 1 总则General 1.1 本技术协议适用于国电建投内蒙古能源有限公司布连电厂一期工程2×660MW国产超超临界燃煤空冷机组的锅炉给水泵组设备，范围为两台机组所配套2台100%容量汽动给水泵、前置泵和本工程两台机组共用的1台电动启动给水泵组，汽动给水泵及其前置泵采用同轴驱动方案。本技术协议提出了设备的功能设计、结构、性能、安装和试验等方面的技术要求。 This specification is only applicable for the boiler feed water pumpsets for Bulian Power Plant Phase I 2×660MW domestic extra-supercritical coal-fired air colded power generation project. The scope includes two sets of 100% capacity turbine driven boiler feed water pumps and its booster pumps for the two Units, and one set of motor driven start-up feed water pumpset shared by the two Units. The tur