科跃环保RTO设备介绍.ppt

KYEF 苏州科跃环保设备有限公司 因为环保 所以自然 创新 拼搏 求实 奋进 RTO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉 蓄热式燃烧技术RTO： 用于有机废气的治理，适应于同一生产线上，因产品不同，废气成分经常发生变化或废气浓度波动较大的场合。应用行业包括汽摩、造船、自行车、家电、集装箱等厂的涂装线、石油化工、橡胶、涂料、粘胶、印刷、漆包线等生产线的废气处理。尤其适用于需要热能回收的企业或烘干线废气处理，可将能源回收用于烘干线，从而达到节约能源的目的。 技术原理 其原理是可燃有机废气在摄氏760～1000度发生热氧化反应，生成二氧化碳和水等。废气首先通过蓄热体加热到接近热氧化温度，而后进入燃烧室进行热氧化，氧化后的气体温度升高，有机物基本转化成二氧化碳和水。净化后的气体，经过另一蓄热体，温度下降，达到排放标准后进行排放。 RTO装置中的蓄热式陶瓷填充床换热器可最大限度回收热能，热回收率大于95%，处理VOCs时不用或使用很少的燃料。若处理低浓度废气，可选装浓缩装置，以降低燃料消耗。 根据客户需求，可设计两室、三室、多室或单室旋转式RTO装置。 RTO(Regenerative Thermal Oxidizer )蓄热式热力废气焚化炉 Storage technology of RTO combustion: For the treatment of organic waste gas, suitable for one production line, for different products, the composition of the exhaust gas often change or exhaust gas concentration fluctuations. Application of industries including automobile, shipbuilding, home appliances, bicycles, container factory coating line, petroleum chemical industry, rubber, coating, adhesive, printing, enameled wire production line of exhaust gas treatment. Especially applicable to enterprises or drying line treatment of waste gas heat recovery, energy recycling can be used for drying line, so as to achieve the purpose of saving energy. Technical principle: Its principle is combustible organic waste gas in 760 ~ 1000 degrees Celsius heat oxidation, carbon dioxide and water. The exhaust gas through the regenerator is first heated to near the thermal oxidation temperature, and then enter the combustion chamber of the gas temperature thermal oxidation, oxidation of organic matter increased, converted into carbon dioxide and water. The purified gas, through a regenerator, temperature drops, reach the discharge standard after discharge. The RTO device in the regenerative ceramic packed bed can maximize the recovery of heat exchanger, heat recovery rate is greater than 95%, VOCs without or with few fuel. If the treatment of low concentration gas, optional concentration device, in order to reduce