BDA-ENG-Compressedairsystemequipmentmaintenance空气压缩机维保标准.docVIP

STANDARD OPERATING PROCEDURES Smith-Nephew Orthopedics (Beijing) Co. Ltd 标准操作规程 施乐辉外科植入物（北京）有限公司 Title 标题: 压缩空气系统设备维护保养 Compressed air system equipment maintenanceSOP#/文件编号BDA-ENG-001Issue Date/发布日期Supersedes/取代NewPage/页码 PAGE 4 of 4Version/版本0  Asterisk（*）indicates change since last revision 星号（*）表示对上一版的变更 介绍 这个程序的目的是描述施乐辉外科植入物（北京）有限公司空气压缩机设备维修计划及设备维护程序由此观察设备的性能。 The program aims to introduce Smith-Nephew Orthopedics (Beijing) Co. Ltd.’s air compressor system maintenance plan and equipment maintenance procedures so as to observe the equipment’s performances. 范围Scope 施乐辉外科植入 物（北京）有限公司空气压缩机设备 Smith-Nephew Orthopedics (Beijing) Co. Ltd.’s air compressor system 参考Reference 《空压机操作与保养手册》 Air Compressor operation and maintain Instruction 《设备维护保养工作记录单》BDAENG004-F002 “Equipment maintenance record” BDAENG004-F002 定义Definite 不适用。N/A 5. 要求 Requirement 5.1 日常检查 Daily check 5.1.1 操作者检查空气压缩机设备前,应对空气压缩机原理有所了解，严格按照《空压机操作与保养手册》要求操作,严禁违章操作 Before operation of air compressor equipment by operator, the principle of air compressor shall be understood and it shall be operated in strict accordance with requirements in the “Compressed air equipment manual”, operation against rules is prohibited. 5.1.2 空气压缩机设备投入运行，操作人员应2小时1次，注意压力、流量、电压、电流是否正常，有无跑水现象，发现问题应及时调整和处理Upon the air compressor equipment put into operation, the operator shall inspect it regularly, pay attention to whether pressure, flow, voltage, current is normal, and whether there is water leakage, if there is problem found, adjustment and disposal shall be made in time. 5.2 日常维护、保养 Daily Maintenance 5.2.1 空气压缩机Air Compressor 5.2.1.1 清除电机内油泥Remove oil sludge within the motor 5.2.1.2 各运动部件加注润滑油 Filling lubricant for all moving parts 5.2.1.3 检查轴承是否正常Check whether the bearing is normal 5.2.1.4 摇测电机绝缘Motor insulation test shaking 5.2.1.5 紧固各接线端子Terminal