带锯机操作规程(三).doc

带锯机操作规程(三) 带锯机操作规程提要：作业中，操作人员应站在带锯机的两侧，跑车开动后，行程范围内的轨道周围不准站人，严禁在运行中上、下跑车 更多精品自财务 带锯机操作规程 1．作业前，检查锯条，如锯条齿侧的裂纹长度超过10mm，锯条接头处裂纹长度超过10mm，以及连续缺齿两个和接头超过三个的锯条均不得使用。裂纹在以上规定内必须在裂纹终端冲一止裂孔。锯条松紧度调整适当后先空载运转，如声音正常，无串条现象时，方可作业。 2．作业中，操作人员应站在带锯机的两侧，跑车开动后，行程范围内的轨道周围不准站人，严禁在运行中上、下跑车。 3．原木进锯前，应调好尺寸，进锯后不得调整。进锯速度应均匀，不能忽快忽慢。 4．在木材的尾端越过锯条后，方可进行倒车。倒车速度不宜过快，要注意木槎、节疤碰卡锯条。 5．平台式带锯作业时，送接料要配合一致。送料、接料时不得将手送进台面。锯短料时，应用推棍送料。回送木料时，要离开锯条50mm以上，并须注意木槎、节疤碰卡锯条。 6．装设有气力吸尘罩的带锯机，当木屑堵塞吸尘管口时，严禁在运转中用木棒在锯轮背侧清理管口。 7．锯机张紧装置的压砣（垂锤），应根据锯条的宽度与厚度调节档位或增减副砣，不得用增加重锤重量的办法克服锯条口松或串条等现象。 8．作业后，切断电源，锁好闸箱，进行擦拭、润滑,清除木屑、刨花。 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideological quality, psychological quality and image quality. The formation of excellent moral education curriculum system and management system, the construction of school. The society, fami