热剧烈变形对Fe-50％Ni合金组织性能的影响.pdfVIP

材料热处理技术号Material Heat Treatment 2011 年 3 月 热剧烈变形对Fe-50%Ni 合金组织性能的影晌 阎海军，喻峰，尹黎荫，孙建春 (重庆科技学院冶金与材料工程学院，重庆 401331) 摘 要:在 900.C 对 Fe-50%Ni(IJ50)合金进行 50%热剧烈变形处理，并对变形前后的 IJ50 材料进行适当氢气保护 热处理。利用金相显微镜、X 射线衍射1Il软磁测量系统对不同处理方式软磁合金的组织结构和性能进行表征。结果表 明.Fe-50%Ni 合金软磁性能比较低.经 50%热剧烈变形的含金磁滞同线圆润，磁性能有所下降，但经氢气保护热处理后 可获得粗大的等轴状晶粒，磁滞国线变得特别修长，软磁性能明显提高。 关键词: 1J50; 热剧烈变形;软磁性能;组织结构 文献标识码:A 文章编号:1001-3814(2011)06幽0150-03 中图分类号:TGl 56.93 Int1uence of Severe Thermal Deformation on Microstructure and Performance of Fe-50% Ni Alloy YAN Haijun, YU Fe吨， YIN Liyin, SUN Jianchun (School 0/Met aJlurgy and Malerials Engineering. Chongqing University 0/Science and Technology. Chongqù啄401331 ， China) Abstract: Fe-50% Ni alloy was treated with hot severe deformation of 50% at 900 C. and proper heat treatrnent of hydrogen protection for 1J50 before and a食er deformation was also carried out. The microstructure and performance of this magnetic alloy were characterized by metallographic microscope. X-ray di世action and magnetic meas山ement. The results show that the per岛rmance of the Fe-50% Ni magnetic alloy is low. and the hysteresis loop of the alloy after hot severe deformation of 50% is round and magnetic properties decrease. but after heat treatment wi由 the hydrogen protection , coarse equiaxed grains occur. hysteresis loop becomes particularly slender. so负 magnetic properties improve obviously. Key words: 1J50; hot severe defonnation; soft magnetic properties; microstructure 软磁材料是在较低的外部磁场强度下即可获得 制造中的难点，提高生产效率，节约资源以及保证合 较大的磁化强度及高密度磁通量的一类材料，即该