热变形对超高强度管线钢组织及变形抗力的影响.pdfVIP

第 31 卷第5 期 东北大学学报(自然科学版) Vo1. 31 ,No. 5 2010 年 5 月 Journal of Northea\tem University(Natural Science) May 2010 热变形对超高强度管线钢 组织及变形抗力的影晌 张凯，邱春林，杜林秀，吴边 (东北大学轧制技术及连轧自动化国家重点实验室，辽宁沈阳 11【削4) 摘 要:运用光学显微镜和电子显微镜对不同热变形条件下组织、析出相进行观察与分析.研究结果表 明:在 1020 C奥氏体再结晶区轧制时，Nb，Ti 以复相形式诱导析出，对组织细化产生一定影响.在保证积累压 下量不变的情况下，奥氏体未再结晶区采用大压下量、少道次的轧制工艺对热变形奥氏体晶粒尺寸影响不大， 对晶内变形带、亚结构和最终组织形貌及尺寸起到一定的作用.同时分析了再结晶轧制温度及未再结晶区轧 制规程对变形抗力的影响. 关键词: X120 超高强度管线钢;热轧工艺:镜钦复合析出相;大压下量:变形带 中图分类号: TG 115.21 +3; TG 301 文献标志码:A 文章编号: 1ω5-3026(201 0)05-0655-05 Effects of 80t Deformation on Microstructure and Deformation Resistance of Ultra-high Strength Pipeline Steel m削G Kai , QIU αun-lin ， DU Lin-xiu , WU Di (The State Key Laboratory of Rolling Automaü俑， Northeastem Univ，盯sity， Shenyang 11∞04 ， αlina. Corres阳ldent: ZI-认NG Kai, E-mail: zha吨k_ neu @ yahoo. 四n.cn) Abstract: The micI1ωtructure of X120 ultra-high strength pipeline st配1 and precipitates during its hot deformation were characterized by optical micros∞pe and el町tronic micros∞pe. The results showed that the N b-Ti diphase pl配ipitate forms at 1 020 t in the austenite recrysta1 1iza.tion region when the st创 is rolled , th山 affecting the grain refinement somewhat. With the accumulated reduction kept unchanged , the effects of heavy reduction and a few number of p出ses on hot-deformed austenite size 盯e small , while the eH四ts on the defonnation bands , substructure, final structure morphol，唱y and grain size 盯e ∞mparatively greater to a certain extent. Moreover , the effects of rolling temperature in recrysta1 1iza.tion region and rolling schedule for non-r，配rystallized region on deformation resistance were 缸181yzed. Key words: X120 ultra-high strength