大理石抛光粉制备低强度等级自密实混凝土的试验研究.pdfVIP

学兔兔 2012年第 12期【总第 278期 ) 混 凝 土 预 拌 混 凝 土 Number 12 in 2012(Total No．278) Concrete READY MIXED CONCRETE doi：10．3969／j．issn．1002—3550．2012．12．028 大理石抛光粉制备低强度等级自密实混凝土的试验研究 谢丽霞。闫红强，夏志远 (中交天津港湾工程研究院，天津 300222) 摘 要：大理石抛光粉颗粒细小，可用作混凝土的掺合料，通过掺加大量的大理石抛光粉，可在保证胶凝材料用量(既保证自密实性)的 前提下，制备成本较低的低强度等级自密实混凝土。采用大理石抛光粉替代部分水泥(10％～5o％)N备C30自密实混凝土，结果表明掺加 20％～30％的大理石抛光粉可有效改善C30自密实混凝土的流动性能、填充性能及抗离析性能，早期强度虽较低，但后期强度有较大幅度 增长，可用于早期强度要求不高的工程中。 关键词：大理石抛光粉；自密实混凝土；强度；耐久性 中图分类号：TU528．041 文献标志码： A 文章编号： 1002—3550(2012)12—0084—04 Utilization of marble polishing powder in C30 self-compacting concrete X『E Li-xia，YANHong-qiang，XIA Zhi-yuan (Tjanjin Port Engineering Institute，Tianjin 300222，China) Abstract： Marble polishing powder，consisting ofultra-fine particles，can be used as a mineral admixture in concrete．Low cost self-compacting concrete(SCC)with desirable workability can be prepared by replacing cement by marble polishing powder．The feasibility ofpreparation ofC30 self-compacting concrete using marble polishing powder Was examined．The results showed that self-compacting concrete with 20％一30％ marble polishing powder had desirable workability，filling ability，and sieve stability，although with relative low early strengths，the late strength of self-compacting concrete increased gradually．Thus，these self-compacting concrete could be used in where high early strength was not required． Keywords：marblepolishingpowders；self-compacting concrete；strength；durability 0 引言 量废渣自密实混凝土的工程应用提供技术支持。 在大理石建筑板材的生产过程中，刮平、定厚、研磨、抛光等工