AI—Si合金的成分和其凝固收缩率与摩尔体积的关系.pdfVIP

学兔兔 Ju1．2015 VOI．64 NO．7 ·609· AI—Si合金的成分和其凝固收缩率与 摩尔体积的关系 李少博，坚增运，许军锋，朱 满，党 博 (西安 L业大学材料与化工学院，陕西西安710021) 摘要：依据阿基米德原理，通过测量台金在熔盐中所受浮力，对不同硅含量铝硅合金的凝固收缩率、液相的摩尔体 积及A1在铝硅合金中的偏摩尔体积进行了研究。结果发现：铝硅合金的凝固收缩率随着硅含量的增大而减小；硅含 量超过25％后，铝硅合金凝固后表现为体积膨胀；当合金硅含量在12．6％至25％之间时，不同铝硅合金在各自液相线 温度下熔体的摩尔体积和在754℃下熔体的摩尔体积均随硅含量的增大而减小，当合金硅含量由25％增大至30％时， 上述两种摩尔体积均随硅含量的增大而增大；随着硅含量由12．6％增大至25％，754℃时Al在不同硅含量铝硅合金熔 体中的偏摩尔体积增大。 关键词：AI．Si合金；凝固收缩率；熔盐；摩尔体积 中图分类号：TG146．2 文献标识码：A 文章编号：1001—4977(2015)07—0609—06 The Relationship of Chemical Compositions，Solidification Shrinkage and Molar Volume of AI—Si Alloys LI Shao—bo，JL~．N Zeng-yun，XU Jun-feng，ZHU Man，DANG Bo (School ofMaterials Science and Chemical Engineering，Xi’all Technological University，Xi’an 710021，Shaanxi，China) Abstract：The study ofthe solidifice，tion shrinkage．the Iiquid molar volumes and the partial molar volumes of A1 content ofaluminum silicon alloys iS performed by measuring the buoyancy forces ofalloys sinking in molten salt,according to Archimedes principle．It’S found that the shrinkage decreases with the increase of Si content． Ⅵmen the Si content is above 25wt．‘I／0．the A1．Si alloys will expand after solidification．When the Si content increases from 12．6wt．％to 25wt．％．the molar volumes ofA1．Si alloy melts at each liquidus temperature tend to decrease,SO does the molar volumes of melts at 754℃。but when the Si content increases from 25wt．％ to 30wt．％，an opposite tendency appears．The partial molar volumes of aluminum in A1．Si alloy melts at 754℃ increase along with the increase ofSi content from 1 2．6wt．％to 25wt．％． Key words：A1．Si alloy；solidificati 3n shrink