变形条件对GH625合金高温变形动态再结晶的影响.pdfVIP

稀有金属 第 34 卷第6 期 2010 年 11 月 Vol. 34 No.6 Nov. 2010 变形条件对 GH625 合金高温变形动态再结晶的影晌 吾志岗，李德富\郭胜利，邹宏辉，胡 捷，彭海健 (北京有色金属研究总院有色金属加工事业部，北京 10∞88) 摘要:采用 Gleeble 高温压缩实验研究了变形条件对GH625 合金高温变形动态再结晶的影响，结果表明:当变形程度较小时，原始晶粒内部 出现大量孪晶，晶界呈现锯齿状凸出;随变形程度的增加，在晶界弓出部位开始形核，形成大量再结晶晶粒，随变形程度进一步增加， GH625 合金动态再结晶体积分数增大，但是再结晶晶粒尺寸元明显变化; GH625 合金动态再结晶是一个受变形温度和应变速率控制的过程，变形温 度越高，动态再结晶越容易形核，应变速率越小，动态再结晶过程进行得越充分。在低应变速率条件下， GH625 合金获得完全动态再结晶组 织的温度随变形速率的升高而升高，而在高应变速率条件下必须考虑变形热效应对合金变形组织的影响。 关键词: GH625 合金;热变形;动态再结晶;变形热效应 doi: 10. 3969/j. issn. 0258 -7076.2010.06.009 中图分类号: TG146. 1; TGll 1. 7 文献标识码:A 文章编号: 0258 -7076(2010)06 -0833-06 Effect of Deformation Conditions on Dynamic Recrystallization of GH625 Nickel-Based Alloy Wu Zhigang , Li Defu. , Guo Shengli , Zou Honghui , Hu Jie , Peng Haijian (丹-ocessi唔Division of Non-Ferroω Met础， General Research Institute for Non-Ferrous 胁时，问时!m邸， China) Abstract: Effects of deformation pr∞ess on dynamic recrystallization of GH625 Nickel-based alloy were studied by isothermal com- pression test conducted on a Gleeble-1500D simulation machine. The results showed that there were a large number of twins and se町a­ ted protrusions appeared at the grain boundary when deformation was within a small scale , while some larger crystalline grain could be found in the pr咄咄ions spreading out of the grain boundary when deformation scale increased. When deformation continued 10 in- crease , the dynamic recrγstallization volume fraction of GH625 alloy increased , but dynamic recryslallization grain size had no signifi- cant changes. The dynamic recrystallization process of GH625 alloy wωcontrolled by deformation temperature and slrain rate. In order 10 obtain a fully