隧道内线路病害产生原因及整治措施(国外英文资料).docVIP

隧道内线路病害产生原因及整治措施(国外英文资料) Causes and measures for the damage of the line in the tunnel Fan xiao, assistant engineer of the nanyang industrial section Abstract: with the increasing speed and volume of the train, the load of the wheels on the orbit is increased, and the geometrical dimension of the orbit is overdone. Tunnel line due to its special environment and lighting conditions, tunnel line of the mud pumping in coal ash pollution, ballast, fasteners, serious rust, raise the gasket super pad, sleeper failure with more, more bad track geometry size and dark pit diseases, such as after the cause of the disease, after careful analysis, the comprehensive improvement of the tunnel line equipment quality improved obviously. Key words: the measures of disease control of tunnel line Introductory remarks JiuLiShan tunnel span 2128 m, in December 2009 to February 2010, JiuLiShan downlink tunnel K311 - K314 + 900 m + 0 m, a total of 27 times in diseases, including automotive tier 3 and 2, 21 on-board 2 levels of disease, 13 human diseases. After careful examination found that tunnel soot pollution, ballast track of the mud pumping, fastener serious corrosion, higher gasket seriously ultra pad, sleeper failure is more, more bad track geometry size and dark pit, and poor lighting, caused by the above main reason JiuLiShan frequent tunnel diseases. Analysis of the causes of the disease in the tunnel The bed is badly polluted Downlink JiuLiShan tunnel in front of the train operation, nanyang Dong Zhuang station, PuShan stop there were three large thermal power plant, so JiuLiShan downlink tunnel through coal column is very much, when the train into the hole of wind makes a lot of coal was wrapped into the tunnel and tunnel smudgy serious ballast. The coal ash reduces the pore ratio of the tunnel, so that the water permeability and the elasticity of the daoist bed are reduced, and the disease of the daoist bed, such as the mortars and the slurry, etc. The daoist was covered with