调理剂和通风方式对污泥生物干化效果的影响.pdfVIP

第 4 卷第5 期 Vol. 4 , No. 5 统咙 J民程 4李银 20 1 0 年 5 月 Chinese Joumal of Environmental Engineering May 2 0 1 0 调理剂和通风方式对污泥生物于化 效果的影响 蒋建国杨勇贾莹杜雪娟杨世辉 (清华大学环境科学与工程系，北京 10∞84) 摘 要 采用了自主设计的污泥牛物干化实验室模拟系统，研究了调理剂、物料配比和通风方式等实验条件对脱水污 泥生物干化的影响效果。研究结果表明，与锯末相比，秸轩有利于反应物料温度的上升，含水率下降程度更大;利用秸轩调 节污泥初始含水率在60% 和 659奇的实验条件下时，物料的平均含水率分别下降了 7% 和69品，当初始含水率 659昏时，生物 堆体的温度和含水率没有明显的变化;与连续通风相比较，间歇通风的实验条件有利于生物堆体的温度的升高和干化效 果;在该实验中，最佳的生物干化条件是以秸轩为调理剂，初始含水率调至 659岛以下，以间歇方式进行通风。 关键词脱水污泥生物干化调理剂通风 中图分类号 X705 文献标识码 A 文章编号 1673-9108( 2010 )05-1167 -04 Effect of amendments and air-flow on biodrying of dehydrated sewage sludge Jiang Jianguo Yang Yong Jia Ying Du Xuejuan Yang Shihui (Department of Environmental Science and Engineering , Tsinghua University , Beijing 10∞84 ， China) Abstract Influences of amendments and air-flow on biodrying of dehydrated sewage sludge were studied u- sing a self-designed experimental equipment. The results showed that the temperature of material was rapidly in- creased and water was easily removed , when straw was used as bulking agent. As initial water content were 60% and 65% , the final water content decreased by 7% and 6% , respectively. Whereas initial water content was higher than 659品. the temperature and water content of material kept consistent. Compared with continuous air- flow , interval air-flow better facilitated the increase of temperature and removal of water of material. The present results proved that optimal condition of biodrying of dehydrated sewage sludge were straw as bulking agent , below 65% of initial water content and interval air-flow.