分段式永磁直线同步电动机的磁阻力 - 电机与控制学报.pdfVIP

14 10 Vol14 No10 2010 10 ELE CTR IC MACH INES AND CONTROL Oct. 2010 王淑红, 熊光煜 ( , 030024) : 针对驱动垂直提升系统的分段式直线同步电动机磁阻力大的问题, 利用磁场能量解 分 由于齿槽存在和铁心开断引起的分段式永磁直线同步电动机的磁阻力, 建立分段式永磁直线同步电 动机的有限元分 模型, 分 电机内磁场分布, 数值法分别计算电机的齿槽引起磁阻力和由于铁心分 段引起的边端磁阻力, 解 分 结果与有限元分 结果相一致, 在定子绕组不通电的情况下, 利用压 力传感器实验测试了分段式 PMLSM 的磁阻力, 与有限元计算结果相对比证实了理论分 的正确性 : 永磁直线同步电机; 分段; 磁阻力; 有限元 : TM 35 : A : 100 - 449X( 2010) 10- 0056- 05 Detent force of segmentalprimary permanent magnet linear synchronousmotor WANG Shuhong, X IONG Guangyu ( College of E lectricity and Pow er Eng ineering, Taiyuan University of Technology, Taiyuan 030024, Ch ina) Abstract: For the problem of large detent force in segmentalprmi ary permanent magnet linear synchro nous motor ( PMLSM ) driving vertical lifting system, the detent forces caused by slotted armature and segmented iron corew ere analyzed analytically using themagneticfield energy, the finite elementm ethod ( FEM) smi u lation model for the PM LSM w as established, themagneticfield d istribution in themotorw as analyzed, and the detent force caused by the slotted arm ature and edge magnetic detent force caused by segmented iron corew ere computed respectively by numericalmethod. The analytical resu ltsw ere consist ent w ith fin ite element analysis resu lts. When stator w inding is not pow ered on, the pressure sensor is used to test the detent force of segmentalprmi ary PMLSM. Comparison ofmeasured detent forcew ith the calculated value by FEM verified the correctness of theoretical analysis. K ey words: perma