NdFeB磁体磁化及温度处理后磁畴结构的变化 Changes in domain structures of NdFeB permanent magnet after magnetization and temperature treatment.pdfVIP

研 究 ·分析 ·实验 B 含量对半硬磁 FeNiMoB 合金薄带 微观结构及磁性能的影响 1 1,2 1,2 1 李琳娜 ，刘 颖 ，李 军 ，杨 凯 （1. 四川大学 材料科学与工程学院，四川成都 610064； 2. 四川大学 先进特种材料及制备加工技术教育部重点实验室，四川成都 610064 ） 摘 要：用真空中频感应炉熔炼得到 Fe － Ni Mo B （x=0, 0.03, 0.1, 0.2 ）合金铸锭，经过多道轧制后 76.6 x 19.2 4.2 x 直接得到半硬磁合金薄带。采用 X 射线衍射仪、金相显微镜及特斯拉计等研究了 B 含量对 FeNiMoB 合金薄带 的显微结构和磁性能的影响。结果表明，随 B 含量的提高，FeNiMoB 合金薄带表面磁通密度（SMFS ）先增大 后减小。添加适量的 B 可以细化合金薄带的晶粒，改善显微结构，提高合金薄带磁性能。当 B 含量为 0.1%时， FeNiMoB 合金薄带具有较好表面磁通密度，SMFS 达到 7mT 。 关键词：FeNiMoB 合金薄带；B 含量；显微结构；磁性能 中图分类号：TM273 文献标识码：A 文章编号：1001-3830(2012)02-0021-03 Effect of B-contents on the microstructures and magnetic properties of semi-hard magnetic FeNiMoB alloy ribbon 1 1,2 1,2 1 LI Lin-na , LIU Ying , LI Jun , YANG Kai 1. School of Material Science and Engineering, Sichuan University, Chengdu 610064, China; 2. Key Laboratoryfor Special and Advanced Materials of the Ministry of Education, Chengdu 610064, China Abstract: Ingots of Fe － Ni Mo B （x=0,0.03,0.1,0.2 ） alloy were prepared by vacuum melting, and 76.6 x 19.2 4.2 x semi-hard magnetic alloy ribbons were obtained by subsquent rolling. Effect of boron content on the microstructure and magnetic properties of both ingots and robbins were investigated by XRD, SEM and Telsameter. The results showed that with increasing boron content, SMFS of the FeNiMoB alloy ribbon increases first, and then decrease. Appropriate boron content results in grain refining, microstructure improvement, and