Common Troubleshooting For Generating Set 发电机组常见故障和排除方法.docVIP

发电机组常见故障及排除方法 Common Troubleshooting For Generating Set 序号 Seq. No. 故障 Fault 可能出现的原因 Possible Reason 排除方法 Troubleshooting 1 油压报警并停机 Low Oil Pressure Alarm and Shutting Down the Set 压力传感器坏 Damaged Pressure Sensor 更换压力传感器 to Replace 润滑油品质差 Inferior Lubricant Quality 更换润滑油 to Replace 机油滤清器脏 Filthy Lubricant Filter 更换滤清器 to Replace 机油泵故障 Faulty Lubricant Pump 更换 to Replace 机油量不足 Shortage of Lubricant 添加机油 to Fill up 2 高水温报警并停机 High Water Temperature Alarm and Shutting down the Set 泠却水不足 Shortage of Coolant 添加 to Fill up 水温传感器坏 Damaged Water Temperature Sensor 更换传感器 to Replace 节温器故障 Faulty Thermostat 更换节温器 to Replace 风扇故障 Faulty Fan 更换风扇 to Replace 进、排风不畅 Unsmooth Air Intake and Exhaust 改造机房 to Reform Machine Room 散热器气流不畅 Bad Ventilation of Radiator 清除散热器上杂物 to Clean the Radiator 风扇皮带松弛 Loosened Belt of Fan 调整 to Adjust 3 燃油低报警 Low Fuel Level Alarm 燃油箱油位低 Low Fuel Level in Fuel Tank 添加燃油 to Fill with Fuel 油位传感器坏 Damaged Fuel Level Sensor 更换同型号传感器 to Replace Fuel Level Sensor of the Same Model Number 4 充电失败告警 Charging Failure Alarm 控制系统无励磁输出 No Excitation from Controlling System 修理或更换 to Repair or Replace 充电机坏 Damaged Charger 更换充电机 to replace 5 发动机不能转动 Engine Fails to Run 急停按钮锁定 Emergency-Shutdown Button Locked 复位 to Reset 启动开关失效 Faulty Start-up Switch 维修或更换 to Repair or Replace 运动部件卡死 Running Parts Blocked 修理 to Repair 6 发动机不能启动 Engine Fails to Start up 油管有空气 Existence of Air in Fuel Piping 排气 to Exhaust Air 油箱无油 No Fuel inside Fuel Tank 添加燃油 to Fill up 蓄电池电量不足 Scarcity of Battery Power 进行充电 to Charge 起动转速过低 Low Starting Speed 检查电池电压 to Check up Battery Voltage 检查或更换起动马达 to Check up or Replace Starting Motor 空气滤清器堵塞 Air Filter Blocked 清洗或更换 to Flush or Replace 高压油泵故障 Faulty High-Pressure Fuel Pump 修理或更换 to Repair or Replace 燃油质量差 Inferior Fuel Quality 更换燃油 to Replace 7 冒白烟或蓝烟 Emission of White or Blue Smoke 机油过多 Excessive Lubricant 排放至不超过油尺上限 to Exhaust not exceeding the Upper Limit or Lubricant Gauge 机油粘度过低 Low Viscosity of Lubricant 更换机油 to Replace 节温阀故障（水温过低）