TSB 05 23 004REVII 2 3 SHIFT FLARE September, （TSB 004年05 23日revii耀斑9月2 3转变,）.pdfVIP

Page 1 of 3 SUBJECT: No: TSB−05−23−004REVII 22−3 SHIFT FLARE3 SHIFT FLARE DATE: September, 2005 MODEL: See below CIRCULATE TO: [ ] GENERAL MANAGER [X] PARTS MANAGER [X] TECHNICIAN [X] SERVICE ADVISOR [X] SERVICE MANAGER [X] WARRANTY PROCESSOR [ ] SALES MANAGER This TSB supercedes TSB−05−23−004REV, to correct the labor time and operation codes in the WARRANTY INFORMATION section of the bulletin. Revised information is indicated by . PURPOSE Some customers may complain of shift flare when shifting from 2nd gear to 3rd gear. This bulletin contains procedures for diagnosing and repairing this condition. New, improved parts are listed in the PARTS INFORMATION section of this bulletin. AFFECTED VEHICLES 1997−02 Mirage 2001−04 Diamante 1999−05 Galant 2000−05 Eclipse 2001−05 Eclipse Spyder 2002−05 Lancer 2004 Lancer Sportback Wagon 2003−05 Outlander 2004−05 Endeavor PROCEDURE 1. Test drive the vehicle to confirm that shift flare occurs at 2−3 shift. 2. Check the ATF level and color. Correct as necessary. Inspect the A/T drain plug for metal debris. 3. Start the engine and warm the ATF to 140−212 degrees F (60−100 degrees C). With constant throttle opening at TPS reading 1.7V − 1.8 V, confirm that the 2−3 upshift occurs between 35 and 40 mph (between 56 and 64 km/h). Continue this driving pattern until the 2−3 shift has occurred five times. a. If the shift flare is not eliminated after the 2−3 shift has occurred five times