论文烘干机2.docVIP

回转式烘干机 摘要: 回转烘干机适用范围广、操作方便、运转率高，在水泥工业中被广泛用于烘干粘土、矿渣、碎石、煤等原、燃料。干燥时，热空气或热烟气将热量传给物料，使水份蒸发，同时依靠通风设备的作用，使干燥设备内的干燥介质不断更新，以排除水汽。干燥设备的形式也是多种多样的，水泥工业中常用的有回转烘干机、流态烘干机、搅拌（悬浮）烘干积极气流式干燥管等。近年来国内外还在研究喷雾干燥装置。这些设备一般都利用热烟气进行对流烘干回转烘干机筒体一般为单直筒型，安装时筒体与水平成一倾斜角度，物料从高端进入，随着筒体的回转缓缓流向低端而后卸出。在中小型水泥厂中，烘干机的筒体长度一般为6-20m，以保证物料在烘干机内的停留时间，满足烘干工艺要求。出热风炉的热气流和物料在筒体内以顺流或逆流形式进行热交换。 关键词: 回转式烘干机、 Rotary dryer to apply a wide range of easy to operate, the functioning of the high rate in the cement industry has been widely used in drying clay, slag, gravel, coal and other original fuel. Dry, hot air or hot flue gas to heat to the material, so that water evaporation, at the same time depend on the role of ventilation, drying equipment so that the drying media constantly updated to exclude the water vapor. The form of drying equipment is varied, the cement industry has commonly used in rotary dryers, fluid dryers, stirring (suspension) a positive air-drying and other drying tube. Is still under study at home and abroad in recent years, spray-drying device. These devices are generally carried out using hot flue gas convection drying cylinder rotary dryers are generally single-Straight type, when installed into a cylinder and horizontal angle, the material from entering the high-end, with the slowly rotating cylinder the flow of low-end and then unloaded. At small and medium-sized cement plant, the drying machine is generally the length of the cylinder 6-20m, to ensure that materials in the dryer to stay within the time requirements to meet the drying process. A hot blast of hot air and material flow in the extinguishers in vivo or in the form of counter-current heat exchange. Keywords: Turn round the type dryer, fluid dryers, stirring 0 引言 0.1 概述 回转式烘干机适用范围广、操作方便、运转率高，在水泥工业中被广泛用于烘干粘土、矿渣、碎石、煤等原、燃料。干燥时，热空气或热烟气将热量传给物料，使水份蒸发，同时依靠通风设备的作用，使干燥设备内的干燥介质不断更新，以排除水汽。干燥设备的形式也是多种多样的，水泥工业中常用的有回转烘干机、流态烘干机、搅拌（悬浮）烘干积极气流式干燥管等。近年来国内外还在研究喷雾干燥装置。这些设备一般都利用热烟气进行对流烘干回转烘干机筒体一般为单直筒型，安装时筒体与水平成一倾斜角度，物料从高端进入，随着筒体的回转缓缓流向低端而后卸出。在中小型水泥厂中，烘