一种内疏水型透水混凝土的研制.pdf

第18卷 第4期 北华大学学报(自然科学版) Vol.18 No.4 2017年7月 JOURNAL OF BEIHUA UNIVERSITY(Natural Science) Jul.2017 文章编号:1009-4822(2017)04-0533-05 DOI:10.11713/ j.issn.1009-4822.2017.04.025 一种内疏水型透水混凝土的研制 曲广雷,王显利,简振鹏,刘梓杨,武东博,徐国华,雷　 刚 (北华大学汽车与建筑工程学院,吉林 吉林　 132013) 摘要:将疏水剂引入透水混凝土中,研制一种内疏水型透水混凝土.采用正交试验,以28 d抗压强度和透水系数 为试验指标,研究孔隙率、水灰比、疏水剂种类3个因素及不同水平对内疏水型透水混凝土性能的影响;通过极 差分析及综合平衡法,分析各因素影响的主次关系,得出最优方案为孔隙率20%,水灰比0.28,荷叶疏水剂;通 过对比试验可知,在最优方案下,掺入4%疏水剂较不掺入疏水剂混凝土强度提高28.9%. 关键词:内疏水透水混凝土;正交试验;抗压强度;透水系数 中图分类号:TU528.9 文献标志码:A 【引用格式】曲广雷,王显利,简振鹏,等.一种内疏水型透水混凝土的研制[J].北华大学学报(自然科学版),2017,18(4): 533-537. Development of Hydrophobic Pervious Concrete Qu Guanglei,Wang Xianli,Jian Zhenpeng,Liu Ziyang,Wu Dongbo,Xu Guohua,Lei Gang (Automotive andArchitectural Engineering College of Beihua University,Jilin 132013,China) Abstract:This paper introduced the hydrophobic agent into pervious concrete to develop a hydrophobic type pervious concrete.Three factorswhich is the goal porosity,water cement ratio and type of hydrophobic agent and different levels influenced on the performance of hydrophobic pervious concrete by using orthogonal experiment, taking28-day compressive strength and permeability coefficient as the test index,and using range analysis and comprehensive balance method,the influence degree of the relationship between primary and secondary factors were obtained. It is concluded that the optimum scheme is goal porosity 20%,water cement ratio 0. 28, hydrophobic agent ;Through the comparative test,it was determined that the strength of the concrete doped with 4% hydrophobic agent was28.9% higher than that of the non-incorporation. Key words:hydrophobic pervious concrete;o