毕业论文设计《汉中市啤酒厂生产污水处理工程设计》.docVIP

陕西理工学院毕业设计 PAGE 陕西理工学院毕业设计 汉中市啤酒厂生产污水处理工程设计 刘祥 （陕西理工学院化学与环境科学学院环境工程101班，陕西，汉中723001） 指导老师：李琛 [摘要]汉中市啤酒厂日生产污水2300t，污水水质为：COD=4300mg/L，BOD=1100mg/L，SS=250mg/L,色度=120度;根据处理的啤酒废水生化性差及出水水质要求，本次设计采用水解酸化+UASB+SBR工艺处理啤酒废水，其工艺流程为：进水→格栅→调节池→提升泵→水解酸化池→UASB→SBR→出水。经该工艺处理后，出水水质能达到我国 《啤酒工业污染物排放标准(GB19821-2005)》。 [关键词]啤酒生产污水；水解酸化；UASB；SBR The engineering design of wastewater treatment in beer production of Hanzhong Liu Xiang (Grade04,Class01,Major Environmental Engineering ,College of Chemical Environment Science,Shaanxi University of Technology, Hanzhong 723001, Shaanxi) Tutor: Li Chen Abstract:Hanzhong city brewery production wastewater of 2300t every day. The designed water quality for BOD,COD,SS and chroma is 4300mg/l,1100mg/l,250mg/l and 120 degrees respectively. According to the treatment of poor biological beer wastewater and effluent water quality requirements,this design will use the beer wastewater hydrolytic acidification + UASB + SBR technique. The process is as follows: Inflow water→Grille→Regulating reservoir→Lift pump→Hydrolysis acidification pool →UASB→SBR→Effluent water. After the process treatment, the effluent quality can reach “the beer industrial pollutants discharge standard(GB19821-2005)”. Key words: Beer production wastewater ;Hydrolytic acidification ;Up-flow Anaerobic Sludge Bed ;Sequencing Batch Reactor Activated Sludge Process 目录 TOC \o 1-3 \h \u HYPERLINK \l _Toc389672826 引言 PAGEREF _Toc389672826 \h 1 HYPERLINK \l _Toc389672827 1 概述 PAGEREF _Toc389672827 \h 1 HYPERLINK \l _Toc389672828 1.1啤酒废水处理的研究现状 PAGEREF _Toc389672828 \h 1 HYPERLINK \l _Toc389672829 1.1.1 好氧处理工艺 PAGEREF _Toc389672829 \h 1 HYPERLINK \l _Toc389672830 1.1.2 厌氧处理工艺 PAGEREF _Toc389672830 \h 3 HYPERLINK \l _Toc389672831 1.2 啤酒废水处理的发展趋势 PAGEREF _Toc389672831 \h 3 HYPERLINK \l _Toc389672832 1.2.1利用啤酒废水生产单细胞蛋白 PAGEREF _Toc389672832 \h 3 HYPERLINK \l _Toc389672833 1.2.2利用啤酒废水培养微藻 PAGEREF _Toc389672833 \h 4 HYPERLINK \l _Toc389672834 1.2.3利用啤酒废水制备微生物絮凝剂 PAGEREF _Toc389