连杆清洗设备的高压喷淋系统设计-应用科技.PDFVIP

第 40 卷第 1 期 应 用 科 技 Vol.40, No.1 2013 年 2 月 Applied Science and Technology Feb. 2013 doi:10.3969/j.issn.1009-671X.201208011 网络出版地址：/kcms/detail/23.1191.U1334.006.html 连杆清洗设备的高压喷淋系统设计 卿前茂, 姜莉莉, 周鑫 广东工业大学 机电工程学院, 广东 广州510006 摘 要：为解决发动机连杆高效清洗问题，利用高压喷淋技术瞬间产生的高温高压特点，开发针对连杆存在的污渍及结 构清洗的专用喷淋清洗系统. 对喷淋系统进行整体设计，包括喷淋管道设计、水泵的选择、喷嘴选择配置、控制阀、净 化系统等，对系统的执行采用PLC 控制. 该系统提高了清洗效率，可以为企业带来可观的经济效益. 关键词：喷淋系统；清洗设备；连杆；可编程控制器 中图分类号：TP69 文献标志码：A 文章编号：1009-671X （2013 ）01-0026-04 Design of high pressure spray system for connecting rod cleaning equipment QING Qianmao, JIANG Lili, ZHOU Xin School of Electromechanical Engineering, Guangdong University of Technology, Guangzhou 510006, China Abstract: The design of high pressure spray system solves the high-efficiency cleaning problem for the connecting rod of generator by taking advantage of the high temperature and high pressure characteristics. A special spray cleaning system was developed to clean stains on the connecting rod, and accomplish structural cleaning as well. This paper gives an overall design for the spray cleaning system, including spray line, selection of water pump, configuration of nozzle, control valve, purification system, etc. The system is implemented using programmable logic controller (PLC) control. The design improved cleaning efficiency, bringing considerable economic benefits for the enterprise. Keywords: spraying system; cleaning equipment; connecting rod; programmable logic controller 1发动机连杆是连接活塞与曲柄，以传递运动和力 成水流错位对喷，形成的漩涡流使连杆在密封清洗箱 的杆件. 而清洁度是衡量连杆使用寿命的质量标准之 中可得到全方位的清洗. 清洗完后，连杆上位进入局 一，为提高其使用寿命而对其进行高效清洗. 在发动 部清洗区，在局部清洗区喷嘴定位、定