高浓度苹果汁生产废水处理工艺研究-生态学专业论文.docxVIP

沉淀分离后与一般浓度清洗废水一起进入沉沙池、分离池后，依次经过水解酸化、气 沉淀分离后与一般浓度清洗废水一起进入沉沙池、分离池后，依次经过水解酸化、气 浮、CASS池、人工湿地和过滤池。系统运行4个月后，出水CoDcr浓度稳定在60～ 90mg／L之间，BOD稳定在10～20mg／L之间；SS稳定在20～60mg／L之间；出水达到 国家污水排放一级标准(GB8978—1996)。 工程的处理废水的总投资为类似废水处理工程的1／2，运行电耗为2／3，在不影 响处理效果的前提下，达到了控制成本的目的。 本研究立足于我国目前浓缩苹果汁生产的实际，从经济和生态角度出发，采用最 适合该厂的处理工艺，较系统的对整个工艺过程进行了探讨，可为与苹果汁废水相似 的其它废水处理工程提供了应用依据和技术支持。 关键词： 高浓度苹果汁废水；工艺选择；设计优化；工程调试。 AbStraCtThe AbStraCt The syrup!is the agricultural product preliminary working product，is s锄e with other agricultural product processing industries， its processing production but has the raw material supply innuenCe the seasonal production the characte“stic． Therefore， the high—strength syrup waStewater production produces the organic waste water has the high potency，the wastewater water Volume and the water quality changes major and the seasonal characteristi己 This experiment for the actual project utilization project，experiments in refers to each highly concentrated organic waste water processing method in me foundation，the union project actual moVement reality，discoVers suits the 10cal reality，the economy and the e矗、ective waste water processing craR．The key s01ution syrup waste water processing difficul够is big，the cost hi曲dimcult problem． The experimental attenlpt aRer pollutes shoulders heaVily ultra filters the ta订nuid to carry on alone processes enters the processing syStem again，mer thus reduces the waste water the pollution load， achieVed 7reduced the f101lowing processing unit the design handling ability goal，the success has solVed the ente叩rise most sensitiVe cost problem， had me high promoted signincance to similar flmit juice waste water processing In the cra丘choicej refers to the domestic and foreign related proj ects experience and the project parameter，proposed suits the local actual craR route initially，the union small scale pectin separation simulation test，obtains the preliminary suitable concentration syrup production waste water processing craR，again passes mrough