火电厂给水再循环管道振动分析与控制-中国测试.PDF

第42卷第9期 中国测试 Vol.42 No.9 2016年9月 CHINA MEASUREMENT TEST September，2016 doi院10.11857/j.issn.1674-5124.2016.09.022 火电厂给水再循环管道振动分析与控制 1 1 2 2 1 金红伟 袁 刘 学 袁 何玉灵 袁 唐贵基 袁 高 运 渊1.华电重工股份有限公司袁北京 100070曰2.华北电力大学机械工程系袁河北 保定 071003冤 摘 要院针对某火电厂给水再循环管道振动的原因和集中位置进行分析并提出相应的控制方案遥 首先建立再循环管 道和水流的实体模型尧支吊架简化模型并进行装配袁然后导入至ANSYS 中进行CFX流体分析袁得到水流作用于管道 内壁的冲击压力并导入至结构力学模块进行二次分析袁再将分析数据传递至模态分析模块进行运算袁得到流固耦合 作用下管系前50阶的固有频率和前6阶振型袁 最后结合实验测试结果分析再循环管道振动的原因和振型最大点位 置分布规律袁并提出相应的支吊架调整干预方案袁调整后管系各阶固有频率有所上升袁管系振动明显好转袁表明所提 控制方案可行尧有效遥 该文工作对于火电厂给水再循环管道振动的监测和控制有参考价值遥 关键词院给水再循环曰管道振动曰模态分析曰振动控制 文献标志码院A 文章编号院1674-5124渊2016冤09-0105-07 Vibration analysis and control on water feeding recycling pipe system of thermal power plant 1 1 2 2 1 JIN Hongwei 袁 LIU Xue 袁 HE Yuling 袁TANG Guiji 袁 GAO Yun 渊1.Huadian Heavy Idustries Co.袁Ltd.袁Beijing 100070袁China曰 2.Department of Mechanical Engineering袁North China Electric Power University袁Baoding 071003袁China冤 Abstract: The vibration cause and control method of the water feeding recycling pipe system in a thermal power plant were analyzed. The 3D models of the pipe袁 the water袁 and the simplified cradle were firstly set up and assembled袁 and then imported into ANSYS CFX for fluid analysis. The pulse pressure was transferred to the inner surface of the pipe to perform a structure calculation袁 based on which the modal analysis was taken to obtain the former 50-order natural frequencies and the former 6-order vibra