含水率及温度对钢渣泡沫混凝土导热系数的影响.PDF

Vol. 35 No. 2 安徽工业大学学报(自然科学版) 第35 卷 第2 期 June 2018 J. of Anhui University of Technology(Natural Science) 2018 年 6 月 文章编号：1671-7872(2018)02-0104-06 含水率及温度对钢渣泡沫混凝土导热系数的影响 张 雪，胡 敏，陈德鹏 (安徽工业大学建筑工程学院，安徽马鞍山243002) 摘要：为充分利用固废资源，探究钢渣应用于无机保温建材领域的潜在价值，用等量钢渣替代水泥制备钢渣泡沫混凝土，采用 重湿度法考察含水率对其导热系数的影响；通过改变导热系数测定仪热板温度研究温度和其导热系数的关系；通过施加周期 性的温-湿度模拟自然环境的变化，研究在自然环境下钢渣泡沫混凝土导热系数的变化规律。结果表明：钢渣泡沫混凝土的导 热系数随含水率的增加而增加，但是增加趋势越来越小；随温度的升高而升高，且二者之有良好的线性关系；随周期性温-湿度 循环次数的增加，导热系数越来越大，但增加的趋势越来越小。 关键词：钢渣；泡沫混凝土；含水率；温度；导热系数 中图分类号：TU 528.2 文献标志码：A doi:10.3969/j.issn. 1671-7872.2018.02.002 Effect of Water Content and Temperature on Thermal Conductivity of Steel Slag Foamed Concrete ZHANG Xue ，HU Min ，CHEN Depeng (School of Civil Engineering and Architecture, Anhui University of Technology, Ma ’anshan 243002, China) Abstract ：To make full use of solid waste resources and explore the potential value of steel slag used in the field of inorganic insulation building materials, steel slag foamed concrete was prepared by using equal amount of steel slag instead of cement, then the effect of water content on its thermal conductivity was investigated by the method of heavy humidity; and the relationship between the temperature and its thermal conductivity was studied by changing the temperature of the hot plate of the thermal conductivity tester; finally the change rule of thermal conductivity of steel slag foamed concrete in natural environment was also studied by applying periodic temperature and humidity to simulate the actual environment. The results show that the thermal conductivity of steel slag foamed concrete increases with the increase of water content, but the increasing tended to be lower and lower;