化学镀Ni-P合金镀层用光亮剂研究.PDF

doi:10.3969/j.issn.1008-7516.2012.04.017 化学镀 Ni-P 合金镀层用光亮剂研究 1 2 1 1 1 刘贯军 ,高艳霞 ,于肖威 ,闫奇 ,李文冉 （1.河南科技学院,河南 新乡 453003 ；2.新乡市科普中心,河南 新乡 453000 ） 摘要：考察了电镀镍用中间体 DEP、PME 、BSI、VS 、PS 、PPS-OH 等在化学镀镍中的使用可行性,用正交试验法对 其用量进行了优化,并研究了各种中间体用量对化学镀镍层光泽度的影响趋势,最后用 quanta 200 型扫描电镜 对使化学镀 Ni-P 合金镀层使用光亮剂前后的表面形貌进行了对比观察与分析,结果表明：电镀所用之光亮剂 中间体对提高化学镀层的光泽度同样有效,并且当光亮剂组分含量为 DEP 45 mg/L、PME 15 mg/L 、BSI 750 mg/L、 VS 30 mg/L 、PS 200 mg/L 、PPS-OH 400 mg/L 、OP-10 10 mg/L 时镀层光亮性最优. 关键词：化学镀镍；光亮剂；正交试验 TQ153 A 1008-7516（2012 ）04-0071-04 中图分类号： 文献标志码： 文章编号： Study on brightener for electroless Ni-P plating 1 2 1 1 1 Liu Guanjun ,Gao Yanxia ,Yu Xiaowei ,Yan Qi ,Li Wenran （1.Henan Institute of Science and Technology,Xinxiang 453003,China ；2.Xinxiang popular science center,Xinxiang 453000,China ） 、 、 、 、 、 Abstract:The feasibility of intermediate DEP PME BSI VS PS PPS -OH applied at Electroless Ni -P Plating, which have applied at electro nickelling,were investigated.Content of the brightener component were optimized by orthogonal test,and their effect on glossiness of electroless Ni-P coating were studied.The surface toppgraphy of the Electroless Ni-P coatings both before and after the brightener used were observed.The result shows that the optimal brightness of the electroless Ni-P plating was obtained when content of DEP,PME,BSI,VS,PS,PPS-OH and OP-10 is 45 mg/L,15 mg/L,750 mg/L,30 mg/L,200 mg/L,400 mg/L and 10 mg/L,respectively. ； ； Key words:elect