谐波磁场下硅钢片磁致伸缩特性分析_张艳丽.doc

2015年7月 第30卷第14期 电 工 技 术 学 报 TRANSACTIONS OF CHINA ELECTROTECHNICAL SOCIETY Vol.30 No. 14 Jul. 2015 谐波磁场下硅钢片磁致伸缩特性分析 张艳丽 李 强 王洋洋 张殿海 任自艳 白保东 谢德馨 （辽宁省现代电工装备理论与共性技术重点实验室（沈阳工业大学），辽宁　沈阳 110870） 摘要 非线性负荷接入电网会导致变压器和电机铁心磁场含有谐波，谐波的存在加剧了铁心 的振动噪声。鉴于目前谐波磁场对硅钢片磁致伸缩特性影响的基础研究还比较缺乏，本文利用一 台精度为10nm/m的单片电工钢片磁致伸缩测量装置，通过控制励磁磁场中三次谐波的幅值和相 位，测量了无取向电工钢片的磁致伸缩波形曲线，讨论了磁场谐波成分的增加对磁致伸缩四次和 六次谐波的影响。在此基础上，通过A计权特性计算了谐波磁场下磁致伸缩引起的电工钢片噪声 分贝值，给出了描述谐波磁场与磁致伸缩及其对应噪声分贝值关系的二维曲面。最后，提出采用 磁弹性间接耦合方法仿真分析了一台永磁同步电机铁心的磁致伸缩形变及其对应的噪声分布。所 得测量数据及仿真结果可为准确分析电机铁心磁致伸缩引起的振动噪声提供参考。 关键词：磁致伸缩　　三次谐波磁场　　振动噪声　　电工钢片　　永磁同步电机 中图分类号：TM315 Analysis on Magnetostrictive Properties of Silicon Steel Sheet Under Harmonic Magnetic Field Zhang Yanli Li Qiang Wang Yangyang Zhang Dianhai Ren Ziyan Bai Baodong Xie Dexin (Liaoning Key Laboratory of Modern Electrical Equipments Theory and Common Technologies (Shenyang University of Technology), Shenyang, Liaoning 110870 China) Abstract The nonlinear load connected into electric grid may cause the presence of higher harmonics of magnetic field in the transform cores and motor cores, which can make the vibration and noise of iron cores more serious. Owing to the lack of basic knowledge about the effect of harmonic magnetic field on magnetostrictive property for the silicon steel sheet at present, this paper measured magnetostrictive waveforms of non-oriented grain electrical steel sheet by means of controlling the magnitude and phase of the third harmonic of magnetic field in a magnetostriction tester with an accuracy of 10nm/m. Also, the effects of the increase of harmonic magnetic field on the fourth and sixth harmonic of magnetostriction were discussed. Further, the decibel value of noise caused by the magnetostriction of electrical steel sheet under harmonic magnetic field was calculated by A-weighted velocity level and the relations between harmonic magnetic field and magnetostriction and the corresponding noise were described by two-dimensional surfaces. Finally, an indirect magnetoelastic cou