皮拉德喷煤管.pptVIP

Fives Pillard ROTAFLAM? V2 (RV2) 多种燃料燃烧器 ROTAFLAM? 燃烧器设置 基本设计演示 燃烧可燃废弃物能力 液态废弃物喷射系统 液态废弃物喷射系统 业绩和实用案例 谢谢! Holcim Rochefort工厂的实际应用(法国) 燃烧器功率 (MW) 窑产量 (TPD) 动量 (N/MW) 废弃物热值百分比 火焰长 (m) 熟料C3S百分比含量 熟料三氧化硫百分比含量 原 燃烧器 44 50% 1100 1100 32 65 15.3 7 15 - - 1.2 0.8 57 - 58 (*) 动物肉 20% + 溶剂 30% 新 燃烧器 原来使用低推力燃烧器 问题: 窑内洁圈 熟料中SO3 含量低 熟料质量差 (C3S低) 窑皮薄 使用大推力燃烧器后: 燃烧量占50% 的可燃废弃物 窑状况稳定 减少 SO2 挥发 耐火砖寿命提高 熟料质量提高 窑内不结圈 Holcim Eclepens工厂的实际应用(瑞士) 煤粉 中心和冷却风 锯末和塑料 动物肉粉和干淤泥 污水 废油，溶剂 废气, 油和润滑油 更换燃烧器的收益效果 (*) 四级筒出口温度降低 35°c 预热器无结皮堵塞 当燃烧100％废弃物时窑产量增加 6% (100 吨/天) 当燃烧 100% (原燃烧器燃烧废弃物时窑尾一氧化碳气体大增) Fives Driving Progress * HERE YOU CAN RECOGNIZE THE SLOTS, WHICH ARE ON THE AXIAL AIR CHANNEL TIP * 2 SUCH FUELS (LIQUID OR SOLID) ARE INJECTED, AS MENTIONED AT THE BEGINNING OF THIS PRESENTATION? THRUE THE CENTRAL PART OF THE BURNER. * Kiln data: nominal capacity: 2.700 to/d, dry process kiln length: 80 m kiln diameter: 4,9 m inner refractory pre-heater: 5 stage cooler type: Satellite Fluff (BPG) data: Main components: plastic, paper, textiles calorific value (LCV): ~ 25 MW/kg fineness: 5 – 20 mm moisture: 8,5 % HOLCIM HOVER IS A CEMENTPLANT IN GERMANY. THIS CASE STUDY IS AN INTERESTING CASE, BECAUSE THE AMOUNT OF WASTE FUEL TO BE BURNED (MIXTURE OF PAPER, PLASTIC, CARPETS,…) IS VERY IMPRESSIF…13 TONS PER HOUR. * INTRODUCTION: SITUATION IN 2006 PROBLEM N° 1: Clinker Quality decreased 24-hours compressive resistance decreased continuously WITH THE PREVIOUS BURNER (OLD PILLARD BURNER), THE CUSTOMER WAS OVER THE YEARS BURNING MORE AND MORE SOLID WASTE FUELS. IN THE SAME TIME, THE QUALITY OF THE CLINKER WAS DECREASING PROGRESSIVELY AND HE HAD SOME PROBLEMS OF CLOGGING IN THE PREHEATER TOWER. PROBLEM N° 2: Clogging at pre-heater tower sulphur volatilisation increased temperature at cyclone 4 increased FIRST, AN OVERALL VIEW OF THE BURNER, WERE YOU CAN RECOGNIZE THE VARIOUS AIR AND FUEL CHANNELS. HERE, A CROSS SECTION OF THE BURNER TIP, WHICH SHOWS MORE I