当前沥青混凝土路面产生不平整的原因及处理措施.pdf

中文摘要 随着我国高等级公路的大量修建，半刚性类材料以及优良的工程性能和显 著的经济效益在我国公路建设中得到了广泛的应用，并在公路建设中越来越占 有特殊的重要地位。同时，我国经济发展日益提高，对于路面平整度要求越来 越高，路面平整度的合格率既反映了行车舒适程度，又反映了施工队伍的技术 水平。然而，半刚性材料的缺点在于抗变形能力低，在温度、湿度变化时易导 致路面结构性破坏，直接影响路面使用性能。针对目前沥青路面出现了不同程 度的坑凹、接缝台阶、波浪、碾压车辙、桥涵与路面接茬不平、跳车等路面不 平整现象，分析产生路面不平整的原因，探讨一下路基处理的措施、路堤填筑 材料的要求、路面基层施工应注意的事项、沥青施工工艺和质量控制。 关键词： 沥青路面；不平整；处理措施； Chinese abstract Along with our country highway building, semi rigid materials and excellent work performance and significant economic benefits in Chinas highway construction has been widely used in highway construction, and more and more holds the special important status. At the same time, the economic development of our country is increasing, the pavement is getting higher and higher demands, the eligibility rate reflected both the degree of driving comfort, but also reflects the technical level of the construction team. However, the shortcomings of semi-rigid material are low deformation resistance, the temperature and humidity changes, easily lead to structural damageroads, directly affects the performance of pavement. Aiming at the different degree of asphalt pavement pit, seams, wave, rutting, step rolling bridge and pavement were introduced, such as the jump uneven pavement roughness phenomenon, analysis of pavement roughness reason, discuss the foundation treatment measures of embankment filling, material requirements, construction of base course of pavement, asphalt matters needing attention construction technology and quality control. Key words: asphalt pavement; roughness; treatment measures; 当前沥青混凝土路面产生不平整的 原因及处理措施 一、 绪论 随着高等级公路的迅速发展，对于路面平整度要求越来越高，路面平整度 的合格率既反映了行车舒适程度，又反映了施工队伍的水平。近三年，我单位 所施工的 G312线眉苋段、 G312线凤眉段及 S304 线安蔺段沥青路面工程，不同 程度的出现了坑凹、接缝台阶、波浪、碾压车辙、桥涵与路面接茬不平、跳