舱壁实验程序.docVIP

舱壁实验程序 舱壁实验程序 PAGE 舱壁实验程序 舱壁实验操作程序 WWT experiment operating procedures WWT Minimum ROB requirements for test kids 物料船上的最小配备量 Quantity Unit Name of the material 1 25 Liter Laboratory pure Methanol ?实验室级别的甲醇 2 6 Liter DI water for testing? 蒸馏水 3 Liter Silver Nitrate 2% 2%的硝酸银溶液? 4 Liter Nitric Acid solution? 20%的硝酸溶液 5 Liter Standard chloric solution? 含有氯离子的标准溶液（10ppm) 6 2 Pcs 500 ml Polyethylene washing bottles 塑料甲醇喷罐 7 Pcs Standard Potassium Permanganate solution %的高锰酸钾溶液? 8 2 Pcs capsules Permanganate crystals? 克每份的高锰酸钾 9 5 Pcs Pipette metric scale 公制的滴液管 10 2 Pcs Plastic funnel for wall wash? WWT用的塑料漏斗 11 3 Liter 500 ml Polyethylene washing bottles 塑料甲醇喷罐 12 1 Pcs Penlight flashlights 笔形手电筒 13 8 Bott Wide mouth glass bottles 150 ml150 广口玻璃瓶 14 12 Pcs 100/50ml Nessler tubes 奈斯勒比色管(100ml 8个，50ml 4个) 15 2 Pcs Test tube rack 试管架 16 1 Pcs Wide mouth vacuum flask 广口保温瓶（2升以上，深度要大于50ml试管高度） 备注：以上配备量是根据我司大多数船舶的三次WWT要消耗的量，如有船舶实际三次WWT的消耗量大于规定量则以实际需要量配备！当船舶的舱壁试验材料的库存量小于最小配备量时应立即开具申请单以便有一个时间上的富余，申请时请注意舱壁试验时甲醇及蒸馏水的消耗量较多，请根据本船的航线及常规装载的货物申请适当的数量。 Note: the above equipped with quantity is according to our most ships WWT three times to the amount of consumption, such as actual vessel is three times the consumption of WWT than specified amount criterion with actual requirement equipped with. When the WWT material inventory is less than the minimum amount of equipped with should be immediately issued an application form to have a time of surplus, application for proper quantity please note methanol and distilled water consumption is more, please according to this the ships course and conventional loading goods. 1.碳氢化合物测试（水溶性）Hydrocarbon test (water-soluble) a) 样品：在100毫升的试管中注入50毫升舱壁取样的甲醇样品，然后加入50毫升的蒸馏水，将混合物摇匀静置10分钟观察； sample: in 100 ml of the test tube injection 50 ml bulkhead sampling methanol samples, then add the 50 ml of distilled water, will shake mixture standing for 10 minutes observations; b) 标准：为便于比较观察，在100毫升的试管中注入50毫升标准甲醇试剂和50毫升的蒸馏水将混合物摇匀静置10分钟后作为标准试剂以作比较； stand