陶砂和钢纤维对轻质超高性能混凝土的影响.pdfVIP

2023年第4期（总第402期） 混凝土 原材料及辅助物料 Number 4 in 2023(Total No.402) Concrete MATERIALAND ADMINICLE doi:10.3969/j.issn.1002-3550.2023.04.012 陶砂和钢纤维对轻质超高性能混凝土的影响 丁庆军1，郭凯正1，程华强² ，雷宇翔1，周昌盛1 （1.武汉理工大学硅酸盐建筑材料国家重点实验室，湖北武汉430070；2.武汉市政建设集团有限公司，湖北武汉430070) 摘要：为利用陶砂与钢纤维做骨架制备出轻自重与超高强度协同设计的轻质超高性能混凝土(LUHPC),研究了不同掺量与 粒径的陶砂、不同掺量与长度的钢纤维对LUHPC工作性能、力学性能和收缩性能的影响规律，并通过SEM对其微结构进行分析。 试验结果表明,增加陶砂的掺量可以有效减少LUHPC的表观密度，但力学性能也会随之下降；钢纤维掺量的增加显著提高了LUHPC 的力学性能，且抗折强度的提升效果最为明显，在体积掺量为2%的情况下，增加钢纤维长度会导致LUHPC的工作性能降低、抗 折强度提升；采用粒径为0.075~4.75mm连续级配的陶砂和长度为13mm的钢纤维制备的LUHPC综合性能最佳。 关键词：陶砂；钢纤维；轻质超高性能混凝凝土；力学性能 中图分类号：TU528.041 文献标志码：A 文章编号：1002-3550(2023)04-0059-05 Influence of pottery sand and steel fiber on lightweight ultra high performance concrete DING Qingjun, GUO Kaizheng, CHENG Huaqiang², LEI Yuxiang,ZHOU Changsheng! (1.State Key Laboratory of Silicate Materials for Architectures, Wuhan University of Technology, Wuhan 430070,China; 2.Wuhua Municipal Construction Group Co., Ltd., Wuhan 430070 China) Abstract: For the use of ceramic sand skeleton was prepared with steel fiber light weight and high strength of collaborative design of lightweight high performance concrete (LUHPC),to study the different content and particle size of ceramic sand, dosage and length of steel fiber on LUHPC working properties, mechanical properties and the influence law of shrinkage performance, and through the SEM analysis of the microstructure.The experimental results show that the apparent density of LUHPC can be effectively reduced by increasing the content of ceramsite sand,but the mechanical properties will also decrease.The mechanical properties of LUHPC were significantly improved with the increase of steel fiber content, and the flexural strength of LUHPC wa