洪荆原油管道添加减阻剂增输试验.pdfVIP

2013钲 1 2013 管 道 技 东 5 设 备 第3期 Pipeline Technique and Equipment No．3 洪荆原油管道添加减阻剂增输试验 翟银平 ，王 军 ，程世宝 (1．中石化管道储运公司湛江输油处，广东湛江 524000；2．中石化管道储运公司荆门输油处，湖北荆门 448002) 摘要：随着荆门石化年加工能力的提高，洪荆原油管道的输送能力不能满足生产需求。为此，在管 道中添加了HG减阻剂，以降低管内摩阻压降。通过对沿程水力摩阻损失计算，确定了增输的“瓶颈” 管段，选择在洪湖首站出站管道加剂，针对不同加剂浓度，对比输量变化，计算出增输率和实际减阻率。 结果表明：在不改变原有现场_7-况条件下，加注减阻剂能显著提高管道的输量，并确定了最佳加剂浓度 为30 mg／L． 关键词：减阻剂；增输率；摩阻损失；加剂浓度 中图分类号：TE8 文献标识码：A 文章编号：1004—9614(2013)03—0014—03 Throughout-increasing Experiment on Hong-jing Crude Oil Pipeline by DRA Injection ZHAI Yin—ping ，WANG Jun ，CHENG Shi—bao (1．SINOPEC PSTC Zhanjiang Oil Transportation Department，Zhanjiang 524000，China； 2．SINOPEC PSTC Jingmen Oil Transportation Department，Jingmen 448002，China) Abstract：The processing capacity of products increases in Jingmen petrochemical company，which obviously is limited by the transportation capacity of Hong-jing crude oil pipeline．However，HG DRA injection in pipeline can deduce the friction pies— sure drop．The“bottleneck”pipe of the throughput increasing is determined through the hydraulic friction loss calculation，which is in the first station at Honghu． the increasing input rate and the actual reduction rate are calculated under the different additive concentrations，compared with the change of throughput．The results show that when the existing site conditions do not change， DRA injection can significantly improve pipeline throughput and determine that the best injection concentration is 30 mg／L． Key words：DRA；throughput increasing rate；friction loss；injection concentration 0 引言 1 管道概况 洪荆输油管道上接仪