环氧富锌防锈底漆.docVIP

环氧富锌防锈底漆 Intended Uses 用途 环氧富锌防锈底漆作钢板抛丸或喷砂后的保养期间约为9个月，可用作桥梁、钢结构等长效防锈之用、快干、抗油、能与大部分防锈漆及面漆配套，其干膜厚度控制在20微米左右，不影响焊接性能。 Applied for protection of shot or girt blasted steel plates, with maintenance period up to approx 9 months Also can be used as long life anticorrosion primer for bridges, and steel structures etc. It is quick dry and compatibility with resist and to oil, It possesses good conventional primers and finishes. If it is applied in thin coat 20 microns , the film does not effect the quality of welding. Product Description 产品简介 环氧富锌防锈底漆灰色，无光，由于锌粉含量高，故有阴极保护作用，防锈性能优异。 Grey. Matt Because of its high content of zinc dust, it has high performance of cathodic protection to the substrates. Product Information 产品数据 Volume Solids 固体份 ≥55% Dry Film Thickness 干膜厚度 35 microns equivalent to 65 microns of wet film 35 微米相当于65微米湿膜厚 Theoretical Coverage 理论涂布率 7.1m2 /Kg 7.1平方米/公斤 Practical? Coverage 实际涂布率 Allow appropriate loss 允许适量损耗 Application Details 施工详述 ? Mix Radio 混合比 A : B 6:1 WT 甲:乙 6:1 WT Method of Application 施工方法 Airless Spray 无空气喷涂 Recommended 推荐采用 Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conventional Spray 传统喷涂 Not Recommended 不推荐采用 Thinner 稀释剂 C003 Cleaner 油漆设备清洗剂 C003 Pot Life 使用期 25℃:8h 25℃:8小时 Storage 贮存期 One year 一年 Drying time 干燥时间 Substrate Temperature 底材温度 Touch Dry 表干 （min） ? Hard Dry ? 硬干 h） Over coating Interval 覆涂间隔 Mix最短 Max最长 25 30 6 3 hours 小时 14days 天 Storage and Handling 贮存与管理 Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;30Kg in 20 liter container 甲:30公斤装于20公升容器中 B:5Kg in 5 liter container 乙:5公斤装于5公升容器中 Flash Point 闪点 Paint media:24 甲组份：漆料24 Curing agent:27℃ 乙组份：固化剂27 Specific Gravity ??比重 Approx 2.2Kg/L 大约2.2公斤/公升 Specification and Surface preparation 技术要求及表面处理 The steel surface: Blast clean to Swedish Standard Sa2.5 or rust-removed manually or with power tool to Swedish Standard St3 钢材表面：喷砂处理达瑞典标准 Sa2.5级或手工、动力工具除锈至St3级。 Safety ? Precautions 安全措施 The product must be used in painting area by pro