中韩造船的差距6.ppt

* Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 30. Excessive Scaffolding at Stern Area 在艉部区域超量的脚手架 Excessively high demand of manpower for the Scaffolding (install remove) 打设和拆除脚手架对劳动力有极其高的需求 Solution 解决措施 Recommend special Jig 建议使用专门的工装架 Hello! Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 31. Dock : Crisis at Engine Room Inside 大坞：机舱内的危机 在机舱内的活儿没有得到组织，引起了主要设备的安装工作、舾装件的安装工作、和合拢焊接工作之间的中断 2. 人力工时的浪费（在大坞阶段进行舾装件的安装对工时的需求要比在分段阶段的需求高得多。 ? Delay of the project due to outfitting works由于舾装工作使项目延期。 Solution 措施 Workload and Progress shall be managed by optimum work-flow and Stage (Need Consultation) 工作负荷和进度要通过优化的作业流和作业阶段来管理（需要顾问） Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 32. 大坞：在合拢阶段进行安装而不是在预合拢（总组）阶段安装 Man-hour 工时 Delays 延期 Crane request 对吊车起重的需求 Solution 解决措施 Finish work at PE stages 在预合拢（总组）阶段完成工作 Pipe Connection, Cabling and Pilot-run of the equipment etc. 管子连接，电缆和设备的碰头等 (Need of Consultation)需要顾问 Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 33. Burn Damage and Cost 烧损和成本 Self-explanatory 不必解释了 Solution 解决措施 Minimize Fire work at Dock Stage 在坞内建造阶段减少动火作业 (Need Consultation) 需要咨询/顾问 Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 34. Cabling at Hull Stage 在合拢阶段的电缆工事 1. Excessively high man-hours 极其高的工时需求 2. Badly influence to other departments’ due to interruption 对其它部门产生严重影响 3. Cables damaged during fire work (of other department) 其它部门的动火作业过程中损坏电缆 Solution 解决措施 Pre-install cables, connect power-line from on-shore facility from to turn on light at dock stage 预先安装电缆，接岸电直到在坞内为照明送电。 (Need Consultation)（需要咨询/顾问） Chinese Shipyard 中国船厂 Korean Shipyard 韩国船厂 35. Machinery and Equipment Protection 机械/设备的保护 Self-explanatory 不必解释了 Solution 解决措施 Proper protection must be made immediately after installation of machinery and equipment (also after trial run at PE stage) 在机械设备安装之后，必须立即进行保护（在总组阶段的动车之后也要立即保护） : Need Consultation 需要咨询/顾问 * * * /R /R