现浇箱梁孔道压浆施工方法.doc

现浇箱梁孔道压浆施工方法 现浇箱梁孔道压浆施工方法提要：压浆前孔道用清水冲洗，高压风吹干，管道真空度稳定在-～-之间；浆体注满管道后，在～下持压2min；压浆最大压力不超过 其它精品 现浇箱梁孔道压浆施工方法 终张拉完毕后，必须在2天之内进行管道压浆作业。采用真空辅助灌浆工艺。压浆时及压浆后3d内，梁体及环境温度不得低于5℃。 （1）、压浆水泥采用强度等级不低于级低碱硅酸盐水泥或低碱普通硅酸盐水泥，掺入粉煤灰应符合《客运专线预应力混凝土预制梁暂行技术条件》条规定。浆体水胶比不超过，不得泌水，流动度控制在30～50s之间。 （2）、压浆前孔道用清水冲洗，高压风吹干，管道真空度稳定在-～-之间；浆体注满管道后，在～下持压2min；压浆最大压力不超过。 （3）、启动电机使搅拌机运转，然后加水，再缓慢均匀地加入水泥，拌合时间不少于1min；然后将调好的水泥浆放入压浆罐，压浆罐水泥浆进口处设×过滤网，以防杂物堵管。 （4）、压浆顺序：先下后上。首先由一端以的恒压力向另一端压送水泥浆，当另一端溢出的稀浆变浓之后，达到规定的稠度后，保压2min以上，封闭出浆口，继续压浆到压力达到，管道出浆口应装有三通管，必需确认出浆浓度与进浆浓度一致时，方可封闭保压，浆体注满管道后，应在下持压2min，压浆最大压力不宜超过。若无漏浆则关闭进浆阀门卸下输浆胶管。 （5）、压浆用的胶管一般不超过30m，若超过30m则压力增加。水泥浆搅拌结束至压入管道的时间间隔不应超过40min。 其它精品 Measures for the routine management of moral education in Middle SchoolsMethod of conventional management of moral education in middle schoolFirst, the guiding ideology:School moral education is an organic whole of the whole education work, always adhere to the school adhere to the moral education, education for this product, and actively promote the quality education, the school building efficient curriculum system of moral education, moral education, improve the sense of attraction and appeal, enhance the moral education work for through and timeliness. Teach everyone, service education and management education, and school moral education work must be with family education and community education closely together, to form a concerted pattern, and strive to create a good atmosphere for education, and to promote the all-round development of students, to establish a scientific moral education full of vigor the For long-term mechanism.Two, the goal of moral education:To guide the students to form the correct world outlook, outlook on life, values, to cultivate students unity and mutual assistance, honest and trustworthy, law-abiding, good quality, hard work, set a good XX students ideological quality, psychological quality and image quality. The formation of excellent moral education curriculum system and man