高压除氧器中英文说明书.docVIP

高压除氧设备 high pressure deaerating equipment 安 装 使 用 说 明 书 Installation and Operation Manual  目 录 CONTENTS 一、设备简介 1. Equipment Introduction 二、结构及原理 2. Construction and Function 三、除氧设备的安装 3. Design, manufacture, installation and inspection of deoxygenating equipment4. Operation of Deoxygenating Equipment 五、除氧设备的检验 5. Inspection of Deoxygenating Equipment 六、除氧设备的停运保护 6. Protection of Non Operating Deoxygenating Equipment 八、附设备外形图 8. Outline Drawing of Equipment 设备简介 1. Equipment Introduction 本设备用于锅炉给水的除氧。 This equipment is used to deoxygenate the boiler feedwater. 1、本设备为热力喷雾淋水盘式除氧装置，由高压除氧器与除氧水箱组成，用于电站锅炉给水的除氧。在正常工作下，利用汽轮机抽汽或压力得到控制且具有安全泻放装置的汽源作为加热蒸汽，将进入除氧器的水加热到与除氧器运行压力相对应的饱和蒸汽温度，根据道尔顿定律，将溶于水的氧与二氧化碳等非凝结气体除去，达到标准规定的除氧水，储存在除氧水箱中，随时准备供给用水的需要。 1). This deaerating equipmentis of spray and packing type, consisting of high pressure deaerator and storage tank. It is applied to feedwater deoxygenation of power station boiler, hot water boiler and other hot water equipment. In normal working condition, turbines extraction steam or other steam source which pressure is under control and has safety relief device will be used as heating steam to heat the water entering the deaerator to the saturation steam temperature corresponding to the operation pressure of the deaerator. According to the Dalton Law, it will eliminate uncondensable gases dissolved in the water, such as oxygen and carbon dioxide, etc., so that the deoxygenated water will satisfy the standard requirements. The deoxygenated water will be stored in the storage tank for supply at any time. 2、本设备适用于在设定、滑压力下作定压运行。定压运行时，备用加热蒸汽通过电动调节阀进入除氧器。根据除氧器内部的设定压力为0.147MPa.a，自动调节阀开度，以控制入口加热蒸汽量。 2). This equipment is applicable to constant pressure and sliding pressure operation under the set pressure. Constant pressure operation under the set pressure ,The heating steam of Assistance enters the deaerator through the motor operated adjust valve. According to the internal set pressure (0.147Mpa.a) of the deaerator, it will automati