汽车电控系统（Automotive electronic control system）.doc

汽车电控系统（Automotive electronic control system） Short-answer questions The contents of the initial test of the engine? Consult customers opinion, engine visual inspection, engine basic inspection, and troubleshooting code 2. What is the engine visual project? Demolition of air filter to check whether there is stolen goods and, when necessary, filter and its surrounding change, check if the vacuum hose burst, aging or crushed, check the route vacuum hose and connector is correct, check whether there is oil leakage, check the computer control system of wire connection status, check each sensor actuator for obvious damage, motor testing into the exhaust manifold and exhaust gas oxygen sensor to see if there is leakage, quite necessary to exclude breakdowns 3. What are the basic idle test steps? Start the engine water temperature at normal operating temperature, turn off all the additional electrical devices, turn off the air conditioning switch, transmission control lever in the N file, connection speed table, tachometer signal column connection diagnosis of IG - socket connector, check the idle, if the idle speed is beyond the scope of regulation, adjust the mixture concentration regulation circuit (VAF) if still do not conform to the requirements, then the troubleshooting process 4. Inspection procedures for ignition timing of the engine? Start the engine water temperature to normal operating temperature, transmission control lever in the N position, make the engine speed is stable with a jumper in idle speed, Internet explorer and E joint, diagnostic socket connections timing lights, will timing signal induction lamp 1 cylinder wire clamp, check the basis points, the K value, the normal range: 8 to 12 degrees, if the basic ignition advance Angle is beyond the scope of regulation, check whether the throttle is fully closed, throttle position sensor of the IDL and E2 connection column is interlinked and throttle timing is normal. 5. Measurement of the closing Angle step