船用分油机跑油故障剖析（Analysis of running oil trouble of marine oil separator）.doc

船用分油机跑油故障剖析（Analysis of running oil trouble of marine oil separator） Marine oil spill fault analysis machine Abstract: in this paper, with the specific fault for practical work in the analysis of the causes, and machine oil often encountered in the management of running turbine oil fault check discharge method is discussed. Key words: ship oil separator oil spill fault case In order to reduce the cost of shipping, the marine oil is more and more poor, to ensure that the main and auxiliary equipment is in good working condition, whether the fuel oil or, to separate processing by machine oil. Machine oil in ship operation almost in a state of long-term work, it will inevitably happen fault is not the same, but the oil leakage is one of the most common faults, so check the ship running fault of oil by the oil separator is one of the essential skills of the marine engineer. The following is a special case of reasons caused by the oil run oil fault examples to illustrate the general method of check row. Fault Example One of a marine oil separator (model: ALFA-LAVAL MOPX 207) the separation of regular maintenance of cleaning barrel disintegration. In the separation barrel overhaul before a long time the oil machine runs normally, the disintegration of the separation cylinder work, thoroughly clean and inspect the parts, and replace all sealing elements (O-ring, seal, ring, valve, plug, etc.) to be installed in the automatic oil operating mode (the ship has been with the mode of normal fault free) under test run oil that does not work, according to the alarm code monitoring unit for net oil exports in the oil pressure low alarm valve switch right case that is the oil spill alarm. Two wheel with machine maker again two times, can not eliminate the faults, thus suspected the automatic control unit fails, then reported to cause the second engineer electrical engineer electrical requirements to help find the results found all the normal electrical electrical engineer. Let re e