正交设计优选鳖甲多糖提取工艺的研究.PDFVIP

正交设计优选鳖甲多糖提取工艺的研究 王慧铭 1 1 2 ，乔建卫 ，孙炜 (1.浙江中医药大学药学院，杭州 310053 ；2.浙江省中医药学会，杭州 310003) 摘要：目的 确定鳖甲多糖的最佳提取工艺，以苯酚硫酸法测定鳖甲多糖含量。方法 采用碱提法提取、醇沉得到鳖甲 多糖；利用苯酚硫酸法显色，在 490 nm 处测定吸光度。结果 碱液浓度为 8%、料液比为 1 ∶25 、提取温度为 60 ℃、提 取时间 8 h 为最佳提取工艺，最佳醇沉浓度为 80%；平均回收率为 100.2%，RSD 为 1.4%(n=9) 。结论 本实验鳖甲多糖 提取及含量测定操作简便、结果准确、重复性好，可用于鳖甲多糖的提取与含量测定。 关键词：鳖甲；多糖；含量测定；提取工艺；正交试验 中图分类号：R284.2 文献标志码：B 文章编号：1007-7693(2010)06-507-03 The Optimization of Extraction Method of Polysaccharides from Carapax Trionycis by Orthognal Test 1 1 2 WANG Huiming , QIAO Jianwei , SUN Wei (1.Zhejiang University of Traditional Chinese Medicine, Hangzhou 310053, China; 2. Association of Traditional Chinese Medicine in Zhejiang, Hangzhou 310003, China) ABSTRACT: OBJECTIVE To study the optimum extration process of polysaccharides from Carapax Trionycis. A spectrophotometry method for content determination of polysaccharides from Carapax Trionycis was established with Phenolsulfuric acid coloration. METHODS Polysaccharides was extracted by NaOH solution and alcohol precipitation from Carapax Trionycis. The contents of po1ysaccharides from Carapax Trionycis were determined by spectrophotometry at 490 nm ．RESULTS The results of orthogonal test in treatment of alkali extraction showed the optimum conditions were as the follows: NaOH concentration was 8%, treatment temperature was 60 ℃, extraction time was 8 hours, the ratio of the material and the solution was 1 ∶25. The average recovery rate was 100.23% and RSD was 1.237%(n=9) ．CONCLUSION The method is proved to be simple, accurate and reliable, and can be used to extract and determine the polysaccharides from Carapax Trionycis ． KEY WORDS: Carapax Trionycis; polysaccharides; determination; extraction technology; ort