水泥砂浆地面施工交底（Cement mortar ground construction disclosure）.docVIP

水泥砂浆地面施工交底（Cement mortar ground construction disclosure） Project name Disclosure position Project number Date, Disclosure content: Cement mortar ground construction 1 range This technology standard applies to the cement mortar floor of industrial and civil construction. 2 construction preparation 2.1 materials and main equipment: 2.1.1 cement: Portland cement, ordinary portland cement, the label should not be less than 425, and strictly prohibit mixing of different varieties, different grades of cement. 2.1.2 sand: medium sand or coarse sand shall be adopted, and the 8mm diameter sieve shall be used, and the mud content shall not be greater than 3%. 2.1.3 main equipment: mixer, trolley, wooden club, wood trowel, scraping trowel and crack downpipe, watering can, shovels, buckets, small long brush, broom, wire brush, line bag, chisel, hammer. 2.2 operating conditions: 2.2.1 ground (or floor) cushion, and buried in the ground, all kinds of pipelines have been completed. The floor has an end through the vertical tube, pipe hole has been blocked dense. There should be room for the water drain. 2.2.2 the +50cm horizontal line of the wall has been played around the wall. The 2.2.3 door frame is secured and protected from the inside of the box to prevent the collision of the trolley. 2.2.4 wall and top plastering have been done. Finished roofing. 3 operation process 3.1 process: Grassroots treatment To Looking for elevation and elastic line To Wet sprinkler To Plastering cake and standard reinforcement To Mixing mortar To Cement paste binding layer To Lay the surface of cement mortar To Cuo Ping wood trowel To The iron float pressure again To Press the light second times To Press the light third times To curing 3.1.1 primary treatment: first to sweep the dust on the grass, with a wire brush and chisel brush net, tick off the skin and ash mortar layer, with 10% caustic soda solution to brush off oil base, and with water to rinse liquid will decrease. 3.1.2 look for the eleva