高压变频器工作产生高次谐波的治理.docVIP

高压变频器工作产生高次谐波的治理 何志清 平煤神马建井一处 X 关注成功！ 加关注后您将方便地在 我的关注中得到本文献的被引频次变化的通知！ 新浪微博 腾讯微博 人人网 开心网 豆瓣网 网易微博 摘????要： 随着高压变频器的推广应用, 工业场所内使用高压变频器的设备越来越多, 相应也产生了一些新的问题, 其中高压变频器对电网的干扰严重影响了供电质量和设备的安全运行。与一般无线电电磁干扰一样, 变频器产生的高次谐波通过传导、电磁辐射和感应耦合3种方式对电源及邻近用电设备产生谐波污染。对现场实践中发现的问题和处理问题的方法进行了研究, 通过在单元输入侧增加滤波器、取消高压电容滤波器后, 变频器运行时高压电源侧6 k V电压波形呈现完好的正弦波, 几乎看不到谐波的影响。原因是每个单元运行后PWM调制产生的谐波被单元滤波器吸收, 不会再通过变压器二次绕组反映到电网侧, 成功消除了高压变频器对电网的干扰, 排除了潜在隐患。 关键词： 高压变频器; PWM; 高次谐波; LCL滤波器; 变压器; 干扰; 作者简介：何志清 (1968—) , 男, 河南洛阳人, 高级工程师, 硕士, 1993年毕业于山东矿业学院, 现从事矿山工程施工管理和配套装备研究工作。 收稿日期：2017-06-10 Operation of high-voltage inverter to produce high-order harmonic He Zhiqing No.1 Mine Construction Bureau, Pingmei Shenma Jiangong Group; Abstract： With the popularization and application of high voltage inverter, high voltage inverter equipment more and more use of industrial premises, the corresponding also produced some new problems, the interference of high voltage converter on power grid has seriously affected the quality of safety operation and power supply equipment.Like the general radio electromagnetic interference, the harmonic generated by the frequency converter produces harmonic pollution to the power supply and the neighboring power equipment through three ways of conduction, electromagnetic radiation and inductive coupling.Study on here and deal with problems found in the practice method, through the input side in high voltage capacitor unit increases the filter, cancel filter, inverter operation of high voltage power supply side voltage waveform 6 k V showed intact sine wave, almost can not see the harmonic influence.Harmonic reason is each unit after the operation of PWM modulation has been absorbed through the filter unit, not the transformer two winding reaction to the grid side, successfully eliminate the interference of high voltage inverter on the grid, eliminate potential risks. Keyword： high voltage frequency converter; PWM; higher harmonic; LCL filter; transformer; interference; Recei