燃料系统培训电厂燃料系统概述部分1final.pptxVIP

波黑斯坦纳瑞1×300MW燃煤电厂燃料系统培训燃料系统培训目录一、电厂燃料系统介绍二、燃料基础知识三、燃料管理燃料系统培训电厂燃料系统介绍Outline on fuel system 燃料系统培训全厂概况 Power plant outline一、机组简介 Units introduction波黑斯坦纳瑞电厂锅炉为CFB燃煤机组，亚临界压力参数、自然循环汽包炉，单炉膛、一次中间再热、燃烧器摆动调温、平衡通风、四角切向燃烧、固态排渣、全钢架悬吊结构，露天布置。300MW纯凝汽轮发电机组，汽轮机型式NZK300-16.67/538/538型、单轴、双缸双排汽、一次再热、直接空冷、纯凝机组。In Bosnia and Herzegovina, Stanaria power plant adopting subcritical pressure parameter, natural circulating drum boiler, single boiler furnace, primary middle reheating, temperature adjustment by burner tilting, balanced ventilation, dry bottom, tangential circle burning, total steel hanged structure, exposed layout. 300MW pure condenser generators, turbine type: NZK300-16.67/538/538, tandem, LP/HP cylinders, double air discharge, primary reheating, direct air cooling, condensers燃料系统培训二、燃煤厂外运输方式及技术条件Factory-out transportation and technical conditions波黑斯坦纳瑞电厂燃煤为斯坦纳瑞本地煤矿所产褐煤，燃煤运输采用煤矿皮带输送机直接进厂。Raw material for Stananria power plant is brown coal produced locally. Coal transportation adopts mine belt conveyor for coal supply三、燃煤Coal（一）煤源及煤质资料Coal source and characteristic dataAnnual coal quantity of STANARI power plant is 250×104 t, and the fuel coal is the lignite produced from local coal mine of Stanari with coal quality data below:燃料系统培训波黑斯坦纳瑞电厂年耗煤量为250×104t/a ，燃煤为本地煤矿所产褐煤，煤质资料如下：序号类型单位设计煤质设计范围最差煤质1固定碳%27.5522.0-33.022.722氢%2.462.1-2.92.163氧%13.110.0-15.410.084氮%0.250.20-0.330.325硫%0.130.10-0.200.26氯+氟%0.0090.004-0.01820.01827灰份（815℃）%7.56.0-12.0128全水份%49.046.0-53.052.59低位热值（LHV）kJ/k10500750010哈氏指数HGI4035-4311挥发份%26.121-28.821.3燃料系统培训输煤皮带系统概述Summary for belt conveyor system本工程来煤为厂外长皮带来煤，厂外长皮带来煤进入CCH-2号转运站。Incoming coal for the project is transported through long belt outside the plant , and enters in transfer station CCH-2.电厂单台机组耗煤量为331t/h，按日运行小时数24h计，全厂1×300MW机组日耗煤量7944t。本期建1个约267 米×103 米的煤场，堆煤高度14.45 米，总贮煤量约145000吨。 可满足1×300MW 机组共计15 天的耗煤量。Coal consumption for each unit: 331t/h, daily coal consumption for 1×300MW based on operating hours(24hs): 7944t. One coal ya