011-纯氧燃烧的有关数据换算.docVIP

OXYGEN LIQUID or GAS UNIT COMPARISON 液态/气态氧气单位比对 8 to 12 mm BTU per short ton of melted glass using air/fuel. 每短吨玻璃使用空气/燃料提供的热量为8 to 12 mm BTU per 5 to 7 mm BTU per short ton of melted glass using oxy/fuel. 每短吨玻璃使用氧气/燃料提供的热量为5 to 7 mm BTU per Will save about 35% of energy requirement with oxygen because less heat leaves the furnace exhaust. 将会减少大概35%的能量需求，原因在于在使用氧气后窑炉排烟量降低，能量损失减少。 One gallon of liquid oxygen (LOx) = 115 scf 1加仑液氧=115 scf（标准立方英尺） One gallon of LOx weighs = 9.524 pounds 1加仑液氧重量=9.524磅 One short ton of liquid oxygen (LOx) = 210 gallons 1短吨液氧=210加仑 One short ton of LOx = 24,150 scf 1短吨液氧=24,150 scf One pound of L Ox = 12.075 scf 1磅液氧=12.075 scf One kg of LOx = 26.62 scf 1千克液氧=26.62 scf One kg of LOx = 0.716 m3 1千克液氧=0.713 m3 One ton of LOx = 716 m3 1吨液氧=716 m3 1 scf = 0.0269 nm3 1 标准立方英尺 = 0.0269 标方 1 nm3 = 37.2 scf 1标方=37.2标准立方英尺 1 volume of natural gas (NG) =2.05 times volume of pure oxygen required. 1体积的天然气(NG)=2.05体积的纯氧 1000 scf of natural gas requires 2050 scf of oxygen to completely burn. 1000标准立方英尺天然气需要2050标准立方英尺氧气才能完全燃烧。 When oxygen is supplied from VPSA use ratio of 2.15 times NG for calculating amount. 使用VPSA供氧时使用NG的用量是计算的2.15倍 One kg of oil requires 3.1 kg of LOx for combustion. (Use 3.2 kg O2 / kg Oil). 1千克重油需要3.1千克液氧助燃3.2 kg O2 / kg Oil One kg of oil requires 2.2196 Nm3 of oxygen gas for combustion. (Use 2.3 Nm3 O2 gas per kg Oil per Combustion Tec). 1千克重油需要2.2196 Nm3氧气助燃 Standard vertical storage tank is 12’ to 15’ Φ by 20’ tall 标准垂直储存罐为 Standard vertical tank holds 9,000 or 11,000 or 13,000 gallons 标准垂直储存罐储存9,000 or 11,000 or 13,000加仑 13,000 gallon tank = short tons of Lox 13000加仑储罐=60短吨液氧 The unit of sales in the USA is in 100 scf units for oxygen. 在美国销售氧气的单位是100 scf Amount of electric power required to produce 100 scf of O2 is between 1.0 and 1.2 kWh. 生产100 scf的氧气的能耗介于1.0 and 1.2 kWh. 50% to 60% reduction in LPG used on front end burners if changed to oxy/fuel. 如果在前炉将燃烧器更换为纯氧燃烧器，则会减少50% to 60%LPG用量 All forehearths