水解酸化 生物接触氧化为主的处理工艺对印染废水处理_毕业设计.docVIP

水解酸化+生物接触氧化为主的处理工艺对印染废水处理_毕业设计 Q 3500m3d COD 500～600mgL BOD5 250mgL PH 10～11 SS 300 ㎎l 色度400倍经处理后应达到下列出水水质COD≤100mgLBOD≤25mgL色度≤40倍pH在6～9SS≤70mgL 达污水排放一级标准 经设计可知COD 885ηBOD 96ηSS 986色度895 经技术经济分析此方案投资总额 430万元废水处理成本为097 元 m3有着良好的经济效益和社会效益且节约用地提高绿化降低能耗的理念在设计中得到充分的实践符合新时代环保的要求 关键词 纺织印染废水水解酸化生物接触氧化 ABSTRACT Aiming at the characteristics of printing and dyeing wastewater a biochemical technological process of hydrolytic acidification integrating contact oxidation was applied to treatment of the printing and dyeing wastewater the HRT for the both were 10h respectively The operating results showed the hydrolytic acidification section could improve the biochemical degradability effectively after hydrolytic acidification the wastewater’s BC value could rise to about 04 from 02-03 effectively ensuring the treating effect of aerobic contact According to the monitoring results by the department of environmental protection COD and BOD5 were below 80mgL and 10mgL respectively COD and BOD5removal rates were over 80 and over 90 respectively The liquid waste processing factory designs scale3500 m3d its raw water fluid matter according to square and present production scale in factory and development request after with factory square native environmental protection section consultation certain following design fluid matter amount of water Q 3500m3d COD 600mgL BOD5 250mgL PH 10～11 SS 300 ㎎l Color degree400times After handles should attain the following a water fluid matter COD≤100mgLBOD≤25mgLPh 6～9SS≤70mgLColor degree≤40 timesreaching the dirty water exhausts a class standard Through design thenCOD 885ηBOD 96ηSS 986color is a 895Was analyzed by technique economy this project investment total amount yuan liquid waste processing cost is 097 yuan m3 have got the good and economic performance with social performanceAnd the economy uses a ground of increase the green turn lowering can consume of principle is in design fulfillment getting well meet the request of the mo