常减压装置拆除施工组织方案.doc

WORD格式-可编辑 专业知识--整理分享 中海石油东营石化有限公司 7万吨/年常减压装置拆除 施工方案 工程名称： 7万吨/年常减压装置拆除工程 工程地点： 中海石油东营石化厂区 编制单位： 生产技术部 编 制： 编制日期： 年 月 日 审 核： 审核日期： 年 月 日 批 准： 批准日期： 年 月 日 目 录 一、工程概况······························································3 二、主要施工内容·························································3 三、编制依据······························································3 四、人员组织······························································3 五、施工要求·····························································4 六、施工进度表··························································5 七、拆除施工方式·························································6 7.1、施工方法····························································6 7.1.1、设备、储罐及管道置换及清理·····································6 7.1.2、管道拆除··························································6 7.1.3、燃料油罐拆除·····················································6 7.1.4、外保温的拆除·····················································6 7.1.5、吊卸·······························································6 7.1.6、现场清理··························································7 八、现场施工安全及防护措施·············································7 TOC \o 1-3 \h \z \u 一、工程概况 根据中海石油炼化有限责任公司【海油炼化财[2013]268号】文件要求，中海石油东营石化有限公司决定于2014年3月对7万吨/年常减压装置进行拆除工作。 二、主要施工内容： 1、7万吨/年常减压装置管廊上部约930米工艺管道，一个燃料油罐； 2、装置区管廊支架； 3、两台真空泵、两个水冷槽、常炉龙门架及空冷平台； 4、工艺平台及两塔附属管线。 三、编制依据 1、《石油化工剧毒、可燃介质管道工程施工及验收规范》SH3501-2002 2、《现场设备、工艺管道焊接工程施工及验收规范》GB50236－98 3、《工业金属管道工程施工及验收规范》GB50235－97 4、《石油化工施工安全技术规定》SH3505－2004 5、《石油化工静电接地设计规范》SH3097－2000 6、《中海石油东营石化有限公司QHSE管理制度》 四、人员组织 为确保7万吨/年常减压装置安全拆除，达到“有组织、有计划，有方案”施工 ，成立中海石油东营石化有限公司7万吨/年常减压装置拆除领导小组。 组 长：韩祚平 副组长：李德录 小组成员：赵树梁、张文光、荣爱民、禹建福 领导小组下设3个专业组： （1）工艺排查组： 组长：荣爱民 组员：季善义、吴爱峰 工艺排查组职责：负责对7万吨/年常减压装置危险源摸底排查，现场确认每天达到施工条件的